Novel fabrication of PZT thick films by an oil-bath based hydrothermal method
Source abstract
Abstract
Abstract This paper introduces an innovative way to prepare lead zirconate titanate thick films near the morphotropic phase boundary using oil-bath based hydrothermal method with magnetic stirring. Undergoing once nucleation process and four-time crystallization process, approximately 10 µm PZT thick films could be obtained. This PZT film performed good ferroelectric and dielectric property. At room temperature, the coercive field (E c ) and the remnant polarization (P r ) were 37.5 kV/cm and 7 μC/cm 2 , respectively. In the frequency range between 1 kHz to 1 MHz, dielectric constant decreased from 300 to 250 and the dielectric loss was below 0.1. These promising results suggest that the oil-bath based hydrothermal method is a good candidate for PZT film fabrication.
Source: openaire · Quality: candidate unverified · Source record ↗
Research context
OpenAlex topics: Ferroelectric and Piezoelectric Materials · Dielectric materials and actuators · Acoustic Wave Resonator Technologies
SciVX discovery tags are terminology-based. OpenAlex topics are source-provided classifications.
References (19)
Show source-provided references
1. Fabrication and characterization of PZT (lead zirconate titanate) bridge-shaped resonator for mass sensing application10.1007/s10832-012-9767-7 ↗
2. Resonant frequency tuning of piezoelectric ultrasonic microsensors by bias voltage application to extra top-electrodes on PZT diaphragms10.1080/00150193.2010.485014 ↗
3. Development and application of piezoelectric materials for ultrasound generation and detection10.1258/ult.2011.011027 ↗
4. Optically isotropic and monoclinic ferroelectric phases in Pb (Zr1−xTix) O3 (PZT) single crystals near morphotropic phase boundary10.1103/PhysRevB.81.172103 ↗
5. Gas flow sputtered thick layers of columnar lead zirconate titanate on silicon wafers for high frequency ultrasound transducers10.1016/j.phpro.2015.08.199 ↗
6. Lead zirconate titanate thick film with enhanced electrical properties for high frequency transducer applications10.1063/1.2956408 ↗
7. High performance screen printed Pb(Zr0.46Ti0.54)O3−Pb (Zn1/3Nb2/3)O3−Pb(Ni1/3Nb2/3)O3 thick films by one-step co-firing method10.1016/j.matlet.2015.03.076 ↗
8. Piezoelectric and dielectric aging of Bi0.5(Na0.82K0.18)0.5TiO3 lead-free ferroelectric thick films10.1063/1.3437637 ↗
9. Characterization of thick film piezoelectric lead zirconate titanate (PZT) ceramics fabricated by tape casting processing
10. Electrical properties of piezoelectric PZT thick film by aerosol deposition method10.6111/JKCGCT.2015.25.6.239 ↗
11. Optimum reaction conditions for lead zirconate titanate thick film deposition by ultrasound-assisted hydrothermal method10.7567/JJAP.55.07KC05 ↗
12. Synthesis of PZT fine particles using Ti3+ precursor at a low hydrothermal temperature of 110°C10.1016/j.ceramint.2010.11.034 ↗
13. Analysis of the state of poling of lead zirconate titanate (PZT) particles in a Zn-ionomer composite10.1080/00150193.2016.1134033 ↗
14. Self-separated hydrothermal lead zirconate titanate thick for high frequency transducer applications10.1063/1.3095504 ↗
15. Study on optimizing ultrasonic irradiation period for thick polycrystalline PZT film by hydrothermal method10.1016/j.ultras.2012.12.003 ↗
16. Microwave-hydrothermal synthesis of barium titanate under stirring condition10.1016/j.ceramint.2009.12.016 ↗
17. Preparation and enhanced electrical properties of grain-oriented (Bi1/2Na1/2)TiO3-based lead-free incipient piezoceramics10.1016/j.jeurceramsoc.2015.03.012 ↗
18. Photoelectron spectroscopy and spectro-microscopy of Pb(Zr, Ti)O3 (111) thin layers: imaging ferroelectric domains with binding energy contrast10.1016/j.apsusc.2015.01.153 ↗
19. Band bending at copper and gold interfaces with ferroelectric Pb(Zr,Ti)O3 investigated by photoelectron spectroscopy10.1016/j.apsusc.2015.02.167 ↗