Production of Portland cement clinker from French Municipal Solid Waste Incineration Bottom Ash
Source abstract
Abstract
The amount of bottom ashes generated from the municipal solid waste incineration is increasing considerably. Therefore their recycling is necessary in order to limit the landfilling that presents environmental issues. The aim of this paper is to recycle Municipal Solid Waste Incineration Bottom Ash from the north of France; as a secondary raw material for Portland cement clinker production. In this order Municipal Solid Waste Incineration Bottom Ash is characterized and then used to substitute raw materials for clinker production at laboratory scale. Substitutions rates up to 12.4 % have been tested. The produced clinkers have been characterized by X-Ray Diffraction and the crystalline phases were quantified by Rietveld analysis. The microstructure has been studied by scanning electronic microscopy. After adding gypsum, the compressive strengths of the corresponding cements were measured at 1, 7 and 28 days. The mineralogical composition of the 28 days hydrated cement pastes were studied by X-Ray Diffraction. The results show that up to 12.4 % of Portland cement raw materials can be replaced by the Municipal Solid Waste Incineration Bottom Ash without changing the mineralogical composition. In addition the compressive strengths of the cement pastes produced with Municipal Solid Waste Incineration Bottom Ash are equivalent to the one without bottom ash.
Source: openalex_inverted_index · Quality: baseline
Research context
OpenAlex topics: Recycling and utilization of industrial and municipal waste in materials production · Concrete and Cement Materials Research · Recycled Aggregate Concrete Performance
SciVX discovery tags are terminology-based. OpenAlex topics are source-provided classifications.
References (63)
Show source-provided references
1. Industrially interesting approaches to ‘low-CO2’ cements10.1016/j.cemconres.2004.01.021 ↗
2. A review of alternative approaches to the reduction of CO2 emissions associated with the manufacture of the binder phase in concrete10.1016/j.cemconres.2015.04.012 ↗
3. Contribution of limestone to the hydration of calcium sulfoaluminate cement10.1016/j.cemconcomp.2015.07.005 ↗
4. Advances in alternative cementitious binders10.1016/j.cemconres.2010.11.012 ↗
5. Eco-efficient cements: potential economically viable solutions for a low-CO 2 cement-based materials industry10.1016/j.cemconres.2018.03.015 ↗
6. Reuse of water purification sludge as raw material in cement production10.1016/j.cemconcomp.2010.02.009 ↗
7. Reuse of water purification sludge as raw material in cement production10.1016/j.cemconcomp.2010.02.009 ↗
8. Incorporation of trace elements in Portland cement clinker: thresholds limits for Cu, Ni, Sn or Zn10.1016/j.cemconres.2011.07.006 ↗
9. Sustainable cement production-present and future10.1016/j.cemconres.2011.03.019 ↗
10. Red mud addition in the raw meal for the production of Portland cement clinker10.1016/j.jhazmat.2004.08.002 ↗
11. Utilization of steel slag for Portland cement clinker production10.1016/j.jhazmat.2007.07.093 ↗
12. Dredged sediments used as novel supply of raw material to produce Portland cement clinker10.1016/j.cemconcomp.2012.02.008 ↗
13. Beneficial reuse of dam fine sediments as clinker raw material10.1016/j.conbuildmat.2019.05.047 ↗
14. Valorisation of recycled concrete sands in cement raw meal for cement production10.1617/s11527-017-0996-8 ↗
15. Oil-based mud cutting as an additional raw material in clinker production10.1016/j.jhazmat.2019.121022 ↗
16. Synthesis and characterization of cement clinker using recycled pulverized oyster and scallop shell as limestone substitutes10.1016/j.jclepro.2020.123987 ↗
17. Eurostat · 2021
18. Municipal solid waste management and waste-to-energy in the context of a circular economy and energy recycling in Europe10.1016/j.energy.2017.11.128 ↗
19. The use of calcium sulfo-aluminate cement as an alternative to Portland Cement for the recycling of municipal solid waste incineration bottom ash in mortar10.1177/0734242X20925170 ↗
20. Utilization of municipal solid waste bottom ash and recycled aggregate in concrete10.1016/j.wasman.2005.10.016 ↗
21. Recycling of municipal solid waste incinerator ash in hot-mix asphalt concrete10.1016/j.conbuildmat.2004.05.010 ↗
22. Utilization of municipal solid waste (MSW) ash in cement and mortar10.1016/j.resconrec.2010.05.002 ↗
23. Risk and performance assessment of cement made using municipal solid waste incinerator bottom ash as a cement kiln feed10.1016/j.resconrec.2019.03.047 ↗
24. Environmental impacts of the use of bottom ashes from municipal solid waste incineration: a review10.1016/j.resconrec.2018.09.011 ↗
25. Pre-treatment and utilisation of municipal solid waste incineration bottom ashes towards a circular economy10.1016/j.conbuildmat.2020.120485 ↗
26. Critical examination of recycled municipal solid waste incineration ash as a mineral source for portland cement manufacture – a case study10.1016/j.resconrec.2019.05.002 ↗
27. Early age hydration of blended cement with different size fractions of municipal solid waste incineration bottom ash10.1016/j.conbuildmat.2017.09.063 ↗
28. Use of incinerator bottom ash in concrete10.1016/S0008-8846(96)00193-7 ↗
29. An investigation of bottom ash as a pozzolanic material10.1016/j.conbuildmat.2018.07.101 ↗
30. Review of MSWI bottom ash utilization from perspectives of collective characterization, treatment and existing application10.1016/j.rser.2017.05.044 ↗
31. Life cycle assessment focusing on food industry wastes10.1016/B978-0-12-391921-2.00015-9 ↗
32. Present and long-term composition of MSW landfill leachate: a review10.1080/10643380290813462 ↗
33. Contemporary environmental issues of landfill leachate: assessment and remedies10.1080/10643389.2013.876524 ↗
34. Development of bottom ash as pozzolanic material10.1061/(ASCE)0899-1561(2003)15:1(48) ↗
35. Application of thermally activated municipal solid waste incineration (MSWI) bottom ash fines as binder substitute10.1016/j.cemconcomp.2016.03.015 ↗
36. Recovery of MSWI and soil washing residues as concrete aggregates10.1016/j.wasman.2010.04.019 ↗
37. Optimal use of MSWI bottom ash in concrete10.1007/s40069-014-0073-4 ↗
38. Thermodynamics of the vitrified bottom ash slag from municipal solid waste incinerators-phase relations of CaO-SiO2-Na2O oxide system10.4028/www.scientific.net/AMR.881-883.574 ↗
39. Incinerator bottom ash (IBA) aerated geopolymer10.1016/j.conbuildmat.2016.02.164 ↗
40. Characterization of bottom ash in municipal solid waste incinerators for its use in road base10.1016/j.wasman.2004.07.004 ↗
41. Construction demolition wastes, Waelz slag and MSWI bottom ash: a comparative technical analysis as material for road construction10.1016/j.wasman.2007.01.016 ↗
42. Management of incinerator residues in Flanders (Belgium) and in neighbouring countries. A comparison10.1016/j.wasman.2004.09.002 ↗
43. Washed waste incineration bottom ash as a raw ingredient in cement production: implications for lab-scale clinker behavior10.1016/j.resconrec.2021.105513 ↗
44. Production of cement clinkers from municipal solid waste incineration (MSWI) fly ash10.1016/j.wasman.2006.06.004 ↗
45. Opportunities and challenges associated with using municipal waste incineration ash as a raw ingredient in cement production – a review10.1016/j.resconrec.2020.104888 ↗
46. Analysis of MSWI bottom ash reused as alternative material for cement production10.1016/j.proenv.2016.02.084 ↗
47. Recycling MSWI bottom and fly ash as raw materials for Portland cement10.1016/j.wasman.2007.04.009 ↗
48. Hammoud · 2019
49. Potential of MSWI bottom ash to be used as aggregate in road building materials10.3846/bjrbe.2018.401 ↗
50. The use of municipal solidwaste incineration ash in various building materials: a Belgian point of view10.3390/ma11010141 ↗
51. Government of France · 2011
52. Bhatty · 2006
53. Incorporation of zinc in calcium sulfoaluminate cement clinker
54. Effect of the clinker composition on the threshold limits for Cu, Sn or Zn10.1016/j.cemconres.2012.05.002 ↗
55. Managing trace elements in Portland cement - Part I: interactions between cement paste and heavy metals added during mixing as soluble salts10.1016/j.cemconcomp.2010.06.002 ↗
56. Managing trace elements in Portland cement - Part II: comparison of two methods to incorporate Zn in a cement10.1016/j.cemconcomp.2011.03.008 ↗
57. Incorporation of waste materials into portland cement clinker synthesized from natural raw materials10.1007/s10853-009-3342-x ↗
58. The chemistry of Portland cement clinker10.1680/adcr.2010.22.4.187 ↗
59. CuO and ZnO addition in the cement raw mix: effect on clinkering process and cement hydration and properties
60. Research review of cement clinker chemistry10.1016/j.cemconres.2015.05.018 ↗
61. Utilization of municipal sewage sludge as additives for the production of eco-cement10.1016/j.jhazmat.2012.02.020 ↗
62. Acceleration of Portland cement with lithium, sodium and potassium silicates and hydroxides10.1016/j.matchemphys.2019.122608 ↗
63. Acceleration of Portland cement with lithium, sodium and potassium silicates and hydroxides10.1016/j.matchemphys.2019.122608 ↗