journal article·2025-11-14Open access

Challenges of Tunnel Support in Low Overburden Zones in Urban Areas—Case Study

Ekrem Bektašević, Satko Filipović, Luka Crnogorac, Kemal Gutić, Zijad Požegić, Rade Tokalić

Applied Sciences· Volume 15· Issue 22

Abstract

This paper systematically analyzes the challenges of stabilizing tunnel excavations in zones with low overburden in urban environments, through an engineering-validated case study of the Kobilja Glava Tunnel. A combined approach involving the New Austrian Tunneling Method (NATM) and the pre-installation of steel pipe umbrellas was applied as the primary pre-support measure under complex geotechnical conditions. The design, drilling, grouting, and formation of the temporary support arch were thoroughly documented, along with the implementation of shotcrete, lattice girders, self-drilling anchors, and reinforcement meshes. A numerical analysis was performed using the PLAXIS 2D software package, encompassing the modeling of deformations, shear forces, axial forces, and bending moments, with precisely defined support parameters. Geodetic monitoring recorded maximum surface settlements of up to 70 mm at an overburden of less than 3 m, while deformations were reduced to 28 mm at an overburden of 20 m. The numerical model confirmed soil plasticization within a 3 m wide zone, with maximum displacements reaching 6.3 cm, consistent with field measurements. Calculated tensile strain and angular distortion were classified according to established building damage criteria, confirming minimal structural impact on adjacent buildings. The applied combination of the NATM and the pipe umbrella pre-support system proved to be an effective and reliable solution for controlling deformations and ensuring excavation stability under conditions of limited rock cover and dense urban development. The obtained results provide a verified framework and practical recommendations for future tunneling projects in similar geotechnical and urban conditions, aiming to enhance safety, stability, and cost-effectiveness.
Source: crossref · Quality: baseline

Research context

OpenAlex topics: Geotechnical Engineering and Analysis · Tunneling and Rock Mechanics · Rock Mechanics and Modeling

SciVX discovery tags are terminology-based. OpenAlex topics are source-provided classifications.

Affiliations

Faculty of Mining, Geology and Civil Engineering, University of Tuzla, Urfeta Vejzagića No. 2, 75000 Tuzla, Bosnia and Herzegovina

Road Direction of Sarajevo Canton, Ministry of Transport of Sarajevo Canton, Reisa Džemaludina Čauševića 1, 71000 Sarajevo, Bosnia and Herzegovina

Faculty of Mining and Geology, University of Belgrade, Djusina 7, 11180 Belgrade, Serbia

References (46)

Show source-provided references
1. Definiranje Optimalnog Razmaka Između Tehnoloških Sekvenci Pri Iskopu Tunela U Lošijoj Stjenskoj Masi
2. Analysis of the groundwater influence on the categorization of the rock mass and support type of the Zenica tunnel on the route of the VC corridor
3. Bektašević, E., Gutić, K., Kadrić, R., Kadrić, S., and Sikira, D. (2024, January 15–17). Deformation analysis during tunnel excavation in poor rock mass. Proceedings of the 8th International Conference on Road and Rail Infrastructures–CETRA, Cavtat, Croatia.10.5592/CO/CETRA.2024.1514 ↗
4. Application of seismic methods for determining the depth of the rock mass damage zone around the excavation profile by blasting10.30574/gjeta.2024.18.3.0051 ↗
5. National Highway Institute (US), and Parsons Brinckerhoff, Quade & Douglas (2010). Technical Manual for Design And Construction of Road Tunnels—Civil Elements.
6. Analysis of ground surface settlement in a shallow tunnel using coupled Eulerian-Lagrangian technique10.1007/s10064-025-04340-w ↗
7. Analysis of Surface Deformations During Excavation of A Small Overburden Tunnel in Weak Rock Masses
8. Shallow tunneling’s impact on surface settlements10.18540/jcecvl10iss4pp18591 ↗
9. Jahangir, E. (2025, October 20). Impacts of Shallow Tunneling in Urban Areas. Mines ParisTech—PSL Research University. Available online: https://alertgeomaterials.eu/wp-content/uploads/2015/03/Shallow-tunnels-Mines-ParisTech.pdf.
10. Site characterisation, deep basement support, construction, and deformation control10.1007/s10706-023-02634-y ↗
11. A new construction method for metro stations in dense urban areas in Shanghai soft ground: Open-cut shafts combined with quasi-rectangular jacking boxes10.1016/j.tust.2022.104530 ↗
12. Advancing Shallow Tunnel Construction in Soft Ground: The Pipe-Umbrella Box Jacking Method10.1177/03611981231225430 ↗
13. Deformation in settlement and grouting remediation of thickened larger-diameter metro shield tunnel in soft soil: A case study
14. Analysis and prediction of dynamic stress concentration in jointed coal using boundary element method10.1016/j.tafmec.2025.105136 ↗
15. Physical feature shared online transfer learning framework for cross-engineering rock mass quality perception during TBM excavation10.1016/j.tust.2025.107111 ↗
16. Jin, H., Yuan, D., Zhou, S., and Zhao, D. (2022). Short-term and long-term displacement of surface and shield tunnel in soft soil: Field observations and numerical modeling. Appl. Sci., 12.10.3390/app12073564 ↗
17. Research on the phenomenon of increasing borehole diameter at the installation of rod anchors in marl using wet technology compared to dry drilling procedure10.30574/gjeta.2025.22.2.0019 ↗
18. Yuan, X., Wang, H., Kang, S., Liu, C., Chen, Y., Zhou, X., Wu, C., Zhu, H., Yang, C., and Zhu, Y. (2023). Factors influencing ground settlement during tunnel proximity construction. Sustainability, 15.10.3390/su151713270 ↗
19. Numeričke analize stabilnosti iskopa tunela ibarac i stabilizacija urušenog dijela, parking niše
20. Li, Y., Zhou, G., Li, T., Tang, C.A., Gong, B., and Wang, K. (2023). Influence of tunnel excavation on the deformation of a frame building. Buildings, 13.10.3390/buildings13030810 ↗
21. Mair, R.J., and Taylor, R.N. (2025, October 20). Bored Tunnelling in the Urban Environments. In Fourteenth International Conference on Soil Mechanics and Foundation Engineering. Proceedings International Society for Soil Mechanics and Foundation Engineering. 1999, Volume 4. Available online: https://www.issmge.org/uploads/publications/1/31/1997_04_0049.pdf.
22. IRGO Consulting d.o.o., and Lotus d.o.o. (2023). Glavni Projekt Izmjene Projekta Tunela Kobilja Glava“ na I Transverzali, od km 3 + 420.00 do km 4 + 180.00, Knjiga D, Mapa D.4 Tunelski Iskop, Lotus d.o.o.
23. Rabcewicz, L. (1964). The New Austrian Tunnelling Method (NATM), Part I–III [PDF Lecture Notes], University of British Columbia. Available online: https://www.eoas.ubc.ca/courses/eosc547/lecture-material/Rabcewicz-NATM.pdf.
24. Jovanović, P. (1978). Izrada Podzemnih Prostorija Velikog Profila, Građevinska knjiga.
25. Displacement control in tunnels excavated by the NATM: 3-D numerical simulations10.1016/j.tust.2003.11.006 ↗
26. Monitoring ground deformation in tunnelling: Current practice in transportation tunnels10.1016/j.enggeo.2004.10.011 ↗
27. The New Austrian Tunneling Method. Part One—Principles of the Method
28. Comprehensive deformation study in the new Austrian tunneling technique tunnel utilising artificial neural network model
29. Nitschke, A., Gall, V., and Ahuja, V. (2009, January 9–11). Modeling of pipe arch canopies in shallow soft ground tunnels constructed by sequential excavation methods. Proceedings of the EURO: TUN 2009 2nd International Conference on Computational Methods in Tunnelling, Bochum, Germany.
30. Bektašević, E., Gutić, K., and Sikira, D. (2024). Tunneling—With Practical Examples, LAP LAMBERT Academic Publishing.
31. Volkmann, G., Button, E., and Schubert, W. (2006, January 17–21). A contribution to the design of tunnels supported by a pipe roof. Proceedings of the ARMA US Rock Mechanics/Geomechanics Symposium, Golden, Colorado. ARMA.10.1016/j.tust.2005.12.213 ↗
32. Load transferring mechanism of pipe umbrella support in shallow-buried tunnels10.1016/j.tust.2014.05.018 ↗
33. TerraRoc (2025, October 20). Pipe Roofing Solutions. Available online: https://terrarocdrilling.com/drilling-equipment/drill-tools/casing-advancement-systems/pipe-roofing/.
34. IRGO Consulting d.o.o., and Lotus d.o.o. (2024). Geotehnička misija G32 br.32, Prijedlog br. 8.2, Lotus d.o.o.
35. Analytical prediction for tunneling-induced ground movements in clays10.1061/(ASCE)1090-0241(1998)124:9(846) ↗
36. Advantages and limitations of the observational method in applied soil mechanics10.1680/geot.1969.19.2.171 ↗
37. ICA-ANN, ANN and multiple regression models for prediction of surface settlement caused by tunneling10.1016/j.tust.2018.04.016 ↗
38. Martos, F. (1958). Concerning an approximate equation of the subsidence trough and its time factors. International strata control congress, Leipzig, Section fur Bergbau; Deutsche Akademie der Wissenschaften zu Berlin.
39. Modelling of Tunnel Behaviour10.1680/igeng.1998.30467 ↗
40. Elmanan, A.A., and Elarabi, H. (2015, January 12–13). Analysis of surface settlement due to tunneling in soft ground using empirical and numerical methods. Proceedings of the The Fourth African Young Geotechnical Engineer’s Conference, Casablanca, Morocco.
41. Hybrid meta-heuristic and machine learning algorithms for tunneling-induced settlement prediction: A comparative study10.1016/j.tust.2020.103383 ↗
42. Cao, L., Cui, W., Qin, Z., Xu, R., Wang, T., and Liu, Y. (2023). Analysis of Arch Forming Factors of Shallow Buried Hard Rock Tunnel under Overlying Load. Buildings, 13.10.3390/buildings13092210 ↗
43. Alsirawan, R., Sheble, A., and Alnmr, A. (2023). Two-Dimensional Numerical Analysis for TBM Tunneling-Induced Structure Settlement: A Proposed Modeling Method and Parametric Study. Infrastructures, 8.10.3390/infrastructures8050088 ↗
44. Impact of fire on tunnels in Hawkesbury sandstone10.1016/j.tust.2006.11.003 ↗
45. Building response to excavation-induced settlement10.1061/(ASCE)0733-9410(1989)115:1(1) ↗
46. Burland, J.B. (1995, January 14–16). Assessment of risk of damage to buildings due to tunnelling and excavatioins. Proceedings of the 1st Int. Conf. on Earthquake Geotech. Engrg., IS-Tokyo’95, Tokyo, Japan.