Mathematical Modeling of Battery Degradation Based on Direct Measurements and Signal Processing Methods
Source abstract
Abstract
This paper proposes and evaluates the behavior of a new health indicator to estimate the capacity fade of lithium-ion batteries and their state of health (SOH). This health indicator is advantageous because it does not require the acquisition of data from full charge–discharge cycles, since it is calculated within a narrow SOC interval where the voltage vs. SOC relationship is very linear and that is within the usual transit range for most practical charge and discharge cycles. As a result, only a small fraction of the data points of a full charge–discharge cycle are required, reducing storage and computational resources while providing accurate results. Finally, by using the battery model defined by the Nernst equation, the behavior of future charge–discharge cycles can be accurately predicted, as shown by the results presented in this paper. The proposed approach requires the application of appropriate signal processing techniques, from discrete wavelet filtering to prediction methods based on linear fitting and autoregressive integrated moving average algorithms.
Source: crossref · Quality: baseline
Research context
OpenAlex topics: Advanced Battery Technologies Research · Advancements in Battery Materials · Fault Detection and Control Systems
SciVX discovery tags are terminology-based. OpenAlex topics are source-provided classifications.
Affiliations
Electronics Engineering Department, Universitat Politècnica de Catalunya, 08034 Barcelona, Spain
Electrical Engineering Department, Universitat Politècnica de Catalunya, 08034 Barcelona, Spain
Funding
Ministerio de Ciencia e Innovación de España · the Generalitat de Catalunya
References (46)
Show source-provided references
1. Lithium-Ion Battery Health Prognosis Based on a Real Battery Management System Used in Electric Vehicles10.1109/TVT.2018.2864688 ↗
2. Validation and verification of a hybrid method for remaining useful life prediction of lithium-ion batteries10.1016/j.jclepro.2018.12.041 ↗
3. Comparison of lithium-ion battery performance at beginning-of-life and end-of-life10.1016/j.microrel.2018.07.077 ↗
4. Quantifying EV battery end-of-life through analysis of travel needs with vehicle powertrain models10.1016/j.jpowsour.2015.01.072 ↗
5. Review of State Estimation and Remaining Useful Life Prediction Methods for Lithium– Ion Batteries10.3390/su15065014 ↗
6. Ben Implementation of an improved Coulomb-counting algorithm based on a piecewise SOC-OCV relationship for SOC estimation of Li-ion battery
7. Jiani, D., Zhitao, L., Youyi, W., and Changyun, W. (2014, January 18–20). A Fuzzy Logic-Based Model for Li-ion Battery with SOC and Temperature Effect. Proceedings of the 11th IEEE International Conference on Control & Automation (ICCA), Taichung, Taiwan.10.1109/ICCA.2014.6871117 ↗
8. Saji, D., Babu, P.S., and Ilango, K. (2019, January 17–18). SoC Estimation of Lithium Ion Battery Using Combined Coulomb Counting and Fuzzy Logic Method. Proceedings of the 4th International Conference on Recent Trends on Electronics, Information, Communication & Technology (RTEICT), Bangalore, India.10.1109/RTEICT46194.2019.9016956 ↗
9. Vidal, C., Kollmeyer, P., Chemali, E., and Emadi, A. (2019, January 19–21). Li-ion Battery State of Charge Estimation Using Long Short-Term Memory Recurrent Neural Network with Transfer Learning. Proceedings of the IEEE Transportation Electrification Conference and Expo (ITEC), Detroit, MI, USA.10.1109/ITEC.2019.8790543 ↗
10. Zhang, M., Liu, Y., Li, D., Cui, X., Wang, L., Li, L., and Wang, K. (2023). Electrochemical Impedance Spectroscopy: A New Chapter in the Fast and Accurate Estimation of the State of Health for Lithium-Ion Batteries. Energies, 16.10.3390/en16041599 ↗
11. Prediction of the Remaining Useful Life of Supercapacitors10.1155/2022/7620382 ↗
12. Temperature effect and kinetics, LiZr2(PO4)3 and Li1.2Al0.2Zr1.8(PO4)3 and electrochemical properties for rechargeable ion batteries10.1002/er.8129 ↗
13. Estimating battery state of health using electrochemical impedance spectroscopy and the relaxation effect10.1016/j.est.2021.103210 ↗
14. Adaptive PDE Observer for Battery SOC/SOH Estimation
15. Buchman, A., and Lung, C. (2018, January 25–28). State of Charge and State of Health Estimation of Lithium-Ion Batteries. Proceedings of the IEEE 24th International Symposium for Design and Technology in Electronic Packaging (SIITME), Iasi, Romania.10.1109/SIITME.2018.8599196 ↗
16. Kallel, A.Y., Petrychenko, V., and Kanoun, O. (2022). State-of-Health of Li-Ion Battery Estimation Based on the Efficiency of the Charge Transfer Extracted from Impedance Spectra. Appl. Sci., 12.10.3390/app12020885 ↗
17. Battery-management system (BMS) and SOC development for electrical vehicles10.1109/TVT.2010.2089647 ↗
18. Ma, Q., Wang, Y., Yang, W., Tao, B., and Zheng, Y. (2019, January 24–27). A novel health index for battery RUL degradation modeling and prognostics. Proceedings of the IEEE 8th Data Driven Control and Learning Systems Conference (DDCLS), Dali, China.10.1109/DDCLS.2019.8909006 ↗
19. Sheraz, M., and Choi, W. (2023). A Novel Technique for Fast Ohmic Resistance Measurement to Evaluate the Aging of Lithium-Ion xEVs Batteries. Energies, 16.10.3390/en16031416 ↗
20. State of charge estimation of Power lithium-ion battery based on an Affine Iterative Adaptive Extended Kalman Filter10.1016/j.est.2022.104472 ↗
21. Zhou, W.W., Lu, Q., and Zheng, Y. (2022). Review on the Selection of Health Indicator for Lithium Ion Batteries. Machines, 10.10.3390/machines10070512 ↗
22. Early-Stage end-of-Life prediction of lithium-Ion battery using empirical mode decomposition and particle filter
23. Battery degradation prediction against uncertain future conditions with recurrent neural network enabled deep learning10.1016/j.ensm.2022.05.007 ↗
24. Degradation Curve Prediction of Lithium-Ion Batteries Based on Knee Point Detection Algorithm and Convolutional Neural Network10.1109/TIM.2022.3181307 ↗
25. Empirical Capacity Measurements of Electric Vehicles Subject to Battery Degradation from V2G Services10.1109/TVT.2021.3093161 ↗
26. Wu, T.H., and Moo, C.S. (2017). State-of-Charge Estimation with State-of-Health Calibration for Lithium-Ion Batteries. Energies, 10.10.3390/en10070987 ↗
27. Movassagh, K., Raihan, A., Balasingam, B., and Pattipati, K. (2021). A Critical Look at Coulomb Counting Approach for State of Charge Estimation in Batteries. Energies, 14.10.3390/en14144074 ↗
28. Ravi Kumar, K.S., Mohanta, D.K., Sastry, V.V., Rajesh, D., Sekhar, O.C., and Varma, M.P.C. (2016, January 14–17). Design and fabrication of coulomb counter for estimation of SOC of battery. Proceedings of the IEEE International Conference on Power Electronics, Drives and Energy Systems (PEDES), Trivandrum, India.10.1109/PEDES.2016.7914473 ↗
29. Investigation of lithium-ion battery degradation mechanisms by combining differential voltage analysis and alternating current impedance10.1016/j.jpowsour.2019.227575 ↗
30. Peng, J., Meng, J., Chen, D., Liu, H., Hao, S., Sui, X., and Du, X. (2022). A Review of Lithium-Ion Battery Capacity Estimation Methods for Onboard Battery Management Systems: Recent Progress and Perspectives. Batteries, 8.10.3390/batteries8110229 ↗
31. Multiscale investigation of discharge rate dependence of capacity fade for lithium-ion battery10.1016/j.jpowsour.2022.231516 ↗
32. Pillareddy, V.R., and Karri, G.R. (2023). MONWS: Multi-Objective Normalization Workflow Scheduling for Cloud Computing. Appl. Sci., 13.10.3390/app13021101 ↗
33. (1970). Time Series Analysis: Forecasting and Control, Holden-Day. [1st ed.].
34. Kozitsin, V., Katser, I., and Lakontsev, D. (2021). Online Forecasting and Anomaly Detection Based on the ARIMA Model. Appl. Sci., 11.10.3390/app11073194 ↗
35. Gómez-Pau, Á., Riba, J.-R., and Moreno-Eguilaz, M. (2020). Time Series RUL Estimation of Medium Voltage Connectors to Ease Predictive Maintenance Plans. Appl. Sci., 10.10.3390/app10249041 ↗
36. Use of the autoregressive integrated moving average (Arima) model to forecast near-term regional temperature and precipitation10.1175/WAF-D-19-0158.1 ↗
37. Chen, J.M. (2020). Economic Forecasting With Autoregressive Methods and Neural Networks. SSRN Electron. J., Available online: https://papers.ssrn.com/sol3/papers.cfm?abstract_id=3521532.10.2139/ssrn.3521532 ↗
38. The Prediction of COVID-19 Pandemic for top-15 Affected Countries using advance ARIMA model10.2196/19115 ↗
39. Multistep prediction of remaining useful life of proton exchange membrane fuel cell based on temporal convolutional network10.1080/15435075.2022.2050377 ↗
40. Extended Kalman filtering for battery management systems of LiPB-based HEV battery packs: Part Modeling and identification10.1016/j.jpowsour.2004.02.032 ↗
41. Hussein, A.A.H., and Batarseh, I. (2011, January 24–28). An overview of generic battery models. Proceedings of the 2011 IEEE Power and Energy Society General Meeting, Detroit, MI, USA.10.1109/PES.2011.6039674 ↗
42. Saha, B., and Goebel, K. (2007). Battery Data Set, NASA Ames Research Centre.
43. Investigation of capacity recovery during rest period at different states-of-charge after cycle life test for prismatic Li(Ni1/3Mn1/3Co1/3)O2-graphite cells10.1016/j.est.2019.01.004 ↗
44. Cycling capacity recovery effect: A coulombic efficiency and post-mortem study10.1016/j.jpowsour.2017.08.090 ↗
45. Investigation of significant capacity recovery effects due to long rest periods during high current cyclic aging tests in automotive lithium ion cells and their influence on lifetime10.1016/j.est.2019.02.015 ↗
46. Application of enhanced empirical wavelet transform and correlation kurtosis in bearing fault diagnosis10.1088/1361-6501/aca690 ↗