Application of Fenton’s reagent degrades dissolved and colloidal substances in old corrugated container white water
Source abstract
Abstract
Abstract Fenton’s reagent has strong oxidizing properties and can effectively remove refractory organic pollutants. Fenton’s reagent was applied to deal with the dissolved colloidal substance (DCS) in the white water of old corrugated container (OCC). The optimum reaction condition on Fenton treatment was analyzed by response surface methodology (RSM) based on response values of DCS and CODCr. The result indicated that the optimized condition is as following, pH is 2.45, a mass ratio of H2O2 and CODCr is 1.1 and a mole ratio of FeSO4 and H2O2 is 0.35. Under the optimum condition of a single factor experiment, the experimental results showed that the removal rate of CODcr and DCS was 90.68 % and 1.61 g/L respectively, which was consistent with the response surface analysis prediction values. During the Fenton oxidation, the particle sizes of DCS decreased, the ions content and turbidity of the white water decreased, however the electrical conductivity and zeta potential of the white water raised slightly. Gas Chromatography-Mass Spectroscopy (GC-MS) analysis proved that benzoic acid and nonandioic acid can be effectively removed by Fenton’s reagent, however the content of dehydroabietic acid decreased by 24.07 %.
Source: crossref · Quality: baseline
Research context
OpenAlex topics: Water Quality Monitoring and Analysis · Water Quality and Pollution Assessment · Water Quality Monitoring Technologies
SciVX discovery tags are terminology-based. OpenAlex topics are source-provided classifications.
Affiliations
Department of College of Light Industry and Food Engineering , Guangxi University , Nanning , 530004 , PR China
Guangxi Key Laboratory of Clean Pulp & Papermaking and Pollution Control , Guangxi University , Nanning , 530004 , PR China
Funding
Natural Science Foundation of Guangxi Province
References (28)
Show source-provided references
1. Brouwer, P.H. (1991) The relationship between zeta potential and ionic demand and how it affects wet-end retention. Tappi J. 48(1):170–179.
2. Chen, J.X. (2003) Analysis of dissolved and colloidal substances generated in deinking. China Pulp Pap. 22(1):43–47.
3. Chen, Linzheng (2015) Study on preparation of non-heterogeneous Fenton catalyst and treatment of dense white water under the network. Master’s Thesis, Zhejiang University of Technology, Zhejiang, China.
4. Chen, G.W., Yang, R.D., Xu, Q.H. (2011) Study on the DCS released during ONP pulping. Pap. Sci. Technol. 30(2):12–15.
5. Crawford, D.S. (1992) Behavior of wastepaper stickies in recycling mills. Appita J. 45(4):3.
6. Fitzhenry, J.W., Hoekstra, P.M., Glover, D. (2000) Enzymatic stickies control in Mow OCC and ONP Furnishes. In: Process and Product Quality Conference, Boston, MA. pp. 985–988.
7. Gilbert, C.D., Hsieh, J.S., Xu, Y., Deng, Y. (2000) Effects of white-water closure on the physical properties of linerboard. Tappi J. 83(4):68.
8. Gruber, E., Grobmann, K., Patzold, R. (1998) Characterization of micro dispersed stickies form recycled paper. Wochenbl. Pap.fabr. 126(13):643–648.
9. Kim, Y.O., Nam, H.U., Park, Y.R., Lee, J.H., Park, T.J., Lee, T.H. (2004) Fenton oxidation process control using oxidation-reduction potential measurement for pigment wastewater treatment. Korean J. Chem. Eng. 21(4):801–805.10.1007/BF02705523 ↗
10. Li, Z.Q. (2005) Study on the mechanism of stickies deposition and its control in secondary fibers recycling. Ph. D. Dissertation, South China University of Technology, Guangdong, China.
11. Li, X.F. (2008) Study on the dissolved and colloidal substances released during the recycling of ONP. Master’s Thesis, Shandong Institute of Light Industry, Shandong, China.
12. Li, X.F., Qin, M.H., Liu, N., Miao, X.Q. (2008) Study on the dissolved and colloidal substances released during the pulping of ONP. Trans. China Pulp Pap. 23(4):75–79.
13. Liang, C. (2011) Effects of extractives on hydrogen peroxide bleachibility and fiber surface properties of SCMP. Ph. D. Dissertation, South China University of Technology, Guangdong, China.
14. Lu, M.-C., Lin, C.-J., Liao, C.-H., Ting, W.-P., Huang, R.-Y. (2001b) Influence of pH on the dewatering of activated sludge by Fenton’s regent. Water Sci. Technol. 44(10):327–332.10.2166/wst.2001.0654 ↗
15. Potter, F.S. (1996) The analysis and chemistry of aluminum based paper machine deposits. In: Proceedings of the Papermakers Conference. TAPPI Press, Atlanta, GA. p. 315.
16. Pérez, M., Torrades, F., García-Hortal, J.A., Domènech, X., Peral, J. (2002) Removal of organic contaminants in paper pulp treatment effluents under Fenton and photo-Fenton conditions. Appl. Catal. B, Environ. 36(1):63–74.10.1016/S0926-3373(01)00281-8 ↗
17. Qian, S.T. (2006) Study on cleaner production and wastewater recycle-circulation in recycled papermaking mills. Master’s Thesis, Chongqing University, Chongqing, China.
18. Reakcja, F., Kontrowersje, D., Chemizmu (2009) Fenton reaction controversy concerning the chemistry. Ecol. Chem. Eng. 16(3):347–358.
19. Saastamoinen, S., Neimo, L., Paulapuro, H. (1995) Some factors affecting desorption of silicate in the white water system of a paper machine. Pap. Puu 77(3):124–129.
20. Tang, W.Z., Tassos, S. (1997) Oxidation kinetics and mechanisms of trihalomethanes by Fenton’s reagent. Water Resour. 31(5):1117–1125.10.1016/S0043-1354(96)00348-X ↗
21. Wang, Z.W. (2013) Measurement of the micro stickies in process waste paper recovery and research on their stability. Ph. D. Dissertation, South China University of Technology, Guangdong, China.
22. Wang, X.Y. (2015) The mechanism of Fenton degradation of lignin and saccharide pollutants in poplar APMP pulping waste liquor. Master’s Thesis, Guangxi University, Nanning, China.
23. Wang, X., Zhan, H.Y., Zhao, G.L., He, B.H., Basta, A.H., Chen, J.X., Zhang, L. (2003a) Physical-chemical characteristics of DCS in the process water of newsprint mill. China Pulp Pap. 37(9):20–24.
24. Wang, X., Zhan, H.Y., Zhao, G.L., He, B.H., Basta, A.H., Chen, J.X., Zhang, L. (2003b) Origins of DCS of news PriniMill’s process water and evaluation of DAF eminency in DCS removal. China Pulp Pap. 22(7):4–7.
25. Zhan, H.J., Hu, H.R., Ni, Y.H. (2007) Characteristics of DCS in high yield pulp and its impact on the filler retention. China Pulp Pap. 26(10):1–5.
26. Zhang, C.H., Qin, M.H., Zhan, H.Y. (2006) Analytical methods for the dissolved and colloidal substances in waste-paper pulp-water system. Shanghai Pap. Mak. 37(1):52–56.
27. Zhang, Xiao, Stebbing, Derrick W., Saddler, John N., Beatson, Rodger P., Kruus, Kristiina (2000) Enzyme Treatments of the Dissolved and Colloidal Substances Present in Mill White Water and the Effects on the Resulting Paper Properties. J. Wood Chem. Technol. 20:3.10.1080/02773810009349639 ↗
28. Zhao, L., Chen, A.J. (2010) Efficiency and characteristic of white water recycling with disc filter. Pap., Pap. Mak. 29(04):4–8.