Role of defects in the electronic properties of Al doped ZnO films deposited by spray pyrolysis
Source abstract
Abstract
The best combination of electronic and optical properties in Al-doped ZnO (AZO) thin films have been archived by vacuum-based processing. However, vacuum-based processing is expensive. Solution processing, on the other hand, results in relatively higher resistivity. Methods are being looked to achieve low electrical resistivity and high transparency through scalable solution-based processing. In this study, pure and aluminium doped zinc oxide thin films were deposited on glass substrate by spray pyrolysis route. The deposited films were vacuum annealed for twenty minutes. Electrical, optical, morphological, and surface-specific properties of zinc oxide and aluminium doped zinc oxide thin film were investigated. The role of oxygen vacancies on the Fermi level and their effect on the conductivity of the films were analyzed. The Fermi level was at 3.21 and 3.31 eV for the pure and Al-doped films, which on vacuum annealing, increased to 3.27 and 3.4 eV, respectively. The work function of the as-deposited zinc oxide and AZO films were 5.65 and 4.38 eV, which on vacuum annealing decreased to 4.05 eV and 4.04 eV, respectively. A carrier concentration, as high as 1.7 × 1020 cm−3 with mobility 50 cm2/Vs and resistivity of the order of 2 × 10–3 Ωcm was achieved for 1 at.% Al-doped ZnO (AZO) film. At the same time, the transparency greater than 82% and a figure of merit 1.44 was achieved, which is one of the best reported values for solution-processed AZO films.
Source: expertdata · Quality: candidate unverified · Source record ↗
Research context
OpenAlex topics: ZnO doping and properties · Gas Sensing Nanomaterials and Sensors · Copper-based nanomaterials and applications
SciVX discovery tags are terminology-based. OpenAlex topics are source-provided classifications.
References (73)
Show source-provided references
1. Minami T (2008) Present status of transparent conducting oxide thin-film development for Indium-Tin-Oxide (ITO) substitutes. Thin Solid Films 516:5822–5828. https://doi.org/10.1016/j.tsf.2007.10.06310.1016/j.tsf.2007.10.063 ↗
2. Kwon CH, Hong H-K, Yun DH et al (1995) Thick-film zinc-oxide gas sensor for the control of lean air-to-fuel ratio in domestic combustion systems. Sens Actuators B Chem 25:610–613. https://doi.org/10.1016/0925-4005(95)85134-810.1016/0925-4005(95)85134-8 ↗
3. Gordon RG (2011) Criteria for choosing transparent conductors materials properties relevant to transparent conductors optical and electrical performance of transparent conductors. MRS Bull 25:52–5710.1557/mrs2000.151 ↗
4. Kim H, Gilmore CM, Piqué A et al (1999) Electrical, optical, and structural properties of indium–tin–oxide thin films for organic light-emitting devices. J Appl Phys 86:6451–6461. https://doi.org/10.1063/1.37170810.1063/1.371708 ↗
5. Pasquarelli RM, Ginley DS, O’Hayre R (2011) Solution processing of transparent conductors: from flask to film. Chem Soc Rev 40:5406–5441. https://doi.org/10.1039/c1cs15065k10.1039/c1cs15065k ↗
6. Lee GH, Yamamoto Y, Kourogi M, Ohtsu M (2001) Blue shift in room temperature photoluminescence from photo-chemical vapor deposited ZnO films. Thin Solid Films 386:117–120. https://doi.org/10.1016/S0040-6090(01)00764-710.1016/S0040-6090(01)00764-7 ↗
7. Ellmer K (2001) Resistivity of polycrystalline zinc oxide films: current status and physical limit. J Phys D Appl Phys 34:3097–3108. https://doi.org/10.1088/0022-3727/34/21/30110.1088/0022-3727/34/21/301 ↗
8. Fahoume M, Maghfoul O, Aggour M et al (2006) Growth and characterization of ZnO thin films prepared by electrodeposition technique. Sol Energy Mater Sol Cells 90:1437–1444. https://doi.org/10.1016/j.solmat.2005.10.01010.1016/j.solmat.2005.10.010 ↗
9. Neumann G (1981) On the defect structure of zinc-doped zinc oxide. Phys status solidi 105:605–612. https://doi.org/10.1002/pssb.222105022010.1002/pssb.2221050220 ↗
10. Hagemark KI (1976) Defect structure of Zn-doped ZnO. J Solid State Chem 16:293–299. https://doi.org/10.1016/0022-4596(76)90044-X10.1016/0022-4596(76)90044-X ↗
11. Kim Y-S, Park CH (2009) Rich variety of defects in ZnO via an attractive interaction between O vacancies and Zn interstitials: Origin of n-type doping. Phys Rev Lett 102:086403. https://doi.org/10.1103/PhysRevLett.102.08640310.1103/PhysRevLett.102.086403 ↗
12. Dixon SC, Sathasivam S, Williamson BAD et al (2017) Transparent conducting n-type ZnO: Sc–synthesis, optoelectronic properties and theoretical insight. J Mater Chem C 5:7585–7597. https://doi.org/10.1039/C7TC02389H10.1039/C7TC02389H ↗
13. Mridha S, Basak D (2007) Aluminium doped ZnO films: electrical, optical and photoresponse studies. J Phys D Appl Phys 40:6902–6907. https://doi.org/10.1088/0022-3727/40/22/00810.1088/0022-3727/40/22/008 ↗
14. Joseph B, Manoj PKK, Vaidyan VKK (2006) Studies on the structural, electrical and optical properties of Al-doped ZnO thin films prepared by chemical spray deposition. Ceram Int 32:487–493. https://doi.org/10.1016/j.ceramint.2005.03.02910.1016/j.ceramint.2005.03.029 ↗
15. Janotti A, Van de Walle CG (2005) Oxygen vacancies in ZnO. Appl Phys Lett 87:122102. https://doi.org/10.1063/1.205336010.1063/1.2053360 ↗
16. Bandopadhyay K, Mitra J (2015) Zn interstitials and O vacancies responsible for n-type ZnO: What do the emission spectra reveal? RSC Adv 5:23540–23547. https://doi.org/10.1039/C5RA00355E10.1039/C5RA00355E ↗
17. Janotti A, Van De Walle CG (2007) Native point defects in ZnO. Phys Rev B Condens Matter Mater Phys 76:1–22. https://doi.org/10.1103/PhysRevB.76.16520210.1103/PhysRevB.76.165202 ↗
18. Aktaruzzaman AF, Sharma GL, Malhotra LK (1991) Electrical, optical and annealing characteristics of ZnO: Al films prepared by spray pyrolysis. Thin Solid Films 198:67–74. https://doi.org/10.1016/0040-6090(91)90325-R10.1016/0040-6090(91)90325-R ↗
19. Song D (2008) Effects of rf power on surface-morphological, structural and electrical properties of aluminium-doped zinc oxide films by magnetron sputtering. Appl Surf Sci 254:4171–4178. https://doi.org/10.1016/j.apsusc.2007.12.06110.1016/j.apsusc.2007.12.061 ↗
20. Ataev B, Bagamadova A, Mamedov V et al (1999) Highly conductive and transparent thin ZnO films prepared in situ in a low pressure system. J Cryst Growth 198–199:1222–1225. https://doi.org/10.1016/S0022-0248(98)01217-210.1016/S0022-0248(98)01217-2 ↗
21. Song D, Widenborg P, Chin W, Aberle AG (2002) Investigation of lateral parameter variations of Al-doped zinc oxide films prepared on glass substrates by rf magnetron sputtering. Sol Energy Mater Sol Cells 73:1–20. https://doi.org/10.1016/S0927-0248(01)00104-010.1016/S0927-0248(01)00104-0 ↗
22. Lee J-H, Ko K-H, Park B-O (2003) Electrical and optical properties of ZnO transparent conducting films by the sol–gel method. J Cryst Growth 247:119–125. https://doi.org/10.1016/S0022-0248(02)01907-310.1016/S0022-0248(02)01907-3 ↗
23. Nakata Y, Okada T, Maeda M (2002) Deposition of ZnO film by pulsed laser deposition at room temperature. Appl Surf Sci 197–198:368–370. https://doi.org/10.1016/S0169-4332(02)00426-910.1016/S0169-4332(02)00426-9 ↗
24. Mondragón-Suárez H, Maldonado A, de la Olvera ML et al (2002) ZnO: Al thin films obtained by chemical spray: effect of the Al concentration. Appl Surf Sci 193:52–59. https://doi.org/10.1016/S0169-4332(02)00011-910.1016/S0169-4332(02)00011-9 ↗
25. Lujala V, Skarp J, Tammenmaa M, Suntola T (1994) Atomic layer epitaxy growth of doped zinc oxide thin films from organometals. Appl Surf Sci 82–83:34–40. https://doi.org/10.1016/0169-4332(94)90192-910.1016/0169-4332(94)90192-9 ↗
26. Park S-HK, Lee J-I, Hwang C-S, Chu HY (2005) Characteristics of organic light-emitting diodes with Al-doped ZnO anode deposited by atomic layer deposition. Jpn J Appl Phys 44:L242–L245. https://doi.org/10.1143/JJAP.44.L24210.1143/JJAP.44.L242 ↗
27. Nunes P, Malik A, Fernandes B et al (1999) Influence of the doping and annealing atmosphere on zinc oxide thin films deposited by spray pyrolysis. Vacuum 52:45–49. https://doi.org/10.1016/S0042-207X(98)00321-210.1016/S0042-207X(98)00321-2 ↗
28. Pandey R, Yuldashev S, Nguyen HD et al (2012) Fabrication of aluminium doped zinc oxide (AZO) transparent conductive oxide by ultrasonic spray pyrolysis. Curr Appl Phys 12:S56–S58. https://doi.org/10.1016/j.cap.2012.05.02710.1016/j.cap.2012.05.027 ↗
29. Islam N, Ghosh TB, Chopra KL et al (1996) XPS and X-ray diffraction studies of aluminium-doped zinc oxide transparent conducting films. Thin Solid Films 280:20–25. https://doi.org/10.1016/0040-6090(95)08239-510.1016/0040-6090(95)08239-5 ↗
30. Jayaraman VK, Álvarez AM, Kuwabara YM et al (2016) Effect of co-doping concentration on structural, morphological, optical and electrical properties of aluminium and indium co-doped ZnO thin films deposited by ultrasonic spray pyrolysis. Mater Sci Semicond Process 47:32–36. https://doi.org/10.1016/j.mssp.2016.02.01110.1016/j.mssp.2016.02.011 ↗
31. Aklilu M, Tai Y (2013) Self-assembled monolayers assisted thin film growth of aluminum doped zinc oxide by spray pyrolysis method. Appl Surf Sci 270:648–654. https://doi.org/10.1016/j.apsusc.2013.01.10710.1016/j.apsusc.2013.01.107 ↗
32. Singh CC, Panda E (2018) Zinc interstitial threshold in Al-doped ZnO film: effect on microstructure and optoelectronic properties. J Appl Phys 123:165106. https://doi.org/10.1063/1.502173610.1063/1.5021736 ↗
33. Gupta H, Singh J, Dutt RN et al (2019) Defect-induced photoluminescence from gallium-doped zinc oxide thin films: influence of doping and energetic ion irradiation. Phys Chem Chem Phys 21:15019–15029. https://doi.org/10.1039/C9CP02148E10.1039/C9CP02148E ↗
34. Otieno F, Airo M, Erasmus RM et al (2017) Doped zinc oxide thin films structural and spectroscopic analysis of ex-situ annealed RF sputtered aluminium doped zinc oxide thin films. J Appl Phys 122:075303. https://doi.org/10.1063/1.499893910.1063/1.4998939 ↗
35. Ohyama M, Kozuka H, Yoko T (2005) Sol-gel preparation of transparent and conductive aluminum-doped zinc oxide films with highly preferential crystal orientation. J Am Ceram Soc 81:1622–1632. https://doi.org/10.1111/j.1151-2916.1998.tb02524.x10.1111/j.1151-2916.1998.tb02524.x ↗
36. Tang W, Cameron DC (1994) Aluminum-doped zinc oxide transparent conductors deposited by the sol-gel process. Thin Solid Films 238:83–87. https://doi.org/10.1016/0040-6090(94)90653-X10.1016/0040-6090(94)90653-X ↗
37. Bindu P, Thomas S (2014) Estimation of lattice strain in ZnO nanoparticles: X-ray peak profile analysis. J Theor Appl Phys 8:123–134. https://doi.org/10.1007/s40094-014-0141-910.1007/s40094-014-0141-9 ↗
38. Agashe C, Marathe BR, Takwale MG, Bhide VG (1988) Structural properties of SnO2: F films deposited by spray pyrolysis technique. Thin Solid Films 164:261–264. https://doi.org/10.1016/0040-6090(88)90146-010.1016/0040-6090(88)90146-0 ↗
39. Islam MN, Samantaray BK, Chopra KL, Acharya HN (1993) Microstructural characterization of transparent conducting aluminium doped zinc oxide films prepared by spray pyrolysis. Sol Energy Mater Sol Cells 29:27–35. https://doi.org/10.1016/0927-0248(93)90089-L10.1016/0927-0248(93)90089-L ↗
40. Hung-Chun Lai H, Basheer T, Kuznetsov VL et al (2012) Dopant-induced bandgap shift in Al-doped ZnO thin films prepared by spray pyrolysis. J Appl Phys 112:083708. https://doi.org/10.1063/1.475920810.1063/1.4759208 ↗
41. Li X, Wang Y, Liu W et al (2012) Study of oxygen vacancies’ influence on the lattice parameter in ZnO thin film. Mater Lett 85:25–28. https://doi.org/10.1016/j.matlet.2012.06.10710.1016/j.matlet.2012.06.107 ↗
42. Ma TY, Lee SC (2000) Effects of aluminum content and substrate temperature on the structural and electrical properties of aluminum-doped ZnO films prepared by ultrasonic spray pyrolysis. J Mater Sci Mater Electron 11:305–309. https://doi.org/10.1023/A:100892531512310.1023/A:1008925315123 ↗
43. Sahal M, Sersar R, Marí B (2017) Preparation of intrinsic and Al-doped ZnO thin layers by spray pyrolysis. Proc 2016 Int Renew Sustain Energy Conf IRSEC 2016:252–256. https://doi.org/10.1109/IRSEC.2016.798405110.1109/IRSEC.2016.7984051 ↗
44. Lee J-H, Park B-O (2004) Characteristics of Al-doped ZnO thin films obtained by ultrasonic spray pyrolysis: effects of Al doping and an annealing treatment. Mater Sci Eng B 106:242–245. https://doi.org/10.1016/j.mseb.2003.09.04010.1016/j.mseb.2003.09.040 ↗
45. Burstein E (1954) Anomalous optical absorption limit in InSb [4]. Phys Rev 93:632–633. https://doi.org/10.1103/PhysRev.93.63210.1103/PhysRev.93.632 ↗
46. Moss TS (1954) The Interpretation of the properties of indium antimonide. Proc Phys Soc Sect B 67:775–782. https://doi.org/10.1088/0370-1301/67/10/30610.1088/0370-1301/67/10/306 ↗
47. Raviendra D, Sharma JK (1985) Electroless deposition of cadmium stannate, zinc oxide, and aluminum-doped zinc oxide films. J Appl Phys 58:838–844. https://doi.org/10.1063/1.33631010.1063/1.336310 ↗
48. Kumar A, Ahmad I (2020) Role of defects and microstructure on the electrical properties of solution-processed Al-doped ZnO transparent conducting films. Appl Phys A 126:1–11. https://doi.org/10.1007/s00339-020-03767-010.1007/s00339-020-03767-0 ↗
49. Kumar V, Swart HC, Ntwaeaborwa OM et al (2013) Origin of the red emission in zinc oxide nanophosphors. Mater Lett 101:57–60. https://doi.org/10.1016/j.matlet.2013.03.07310.1016/j.matlet.2013.03.073 ↗
50. Lau WM, Huang LJ, Bello I et al (1994) Modification of surface band bending of diamond by low energy argon and carbon ion bombardment. J Appl Phys 75:3385–3391. https://doi.org/10.1063/1.35701610.1063/1.357016 ↗
51. Chen M, Wang X, Yu Y et al (2000) X-ray photoelectron spectroscopy and auger electron spectroscopy studies of Al-doped ZnO films. Appl Surf Sci 158:134–140. https://doi.org/10.1016/S0169-4332(99)00601-710.1016/S0169-4332(99)00601-7 ↗
52. Chen Z, Zhan G, Wu Y et al (2014) Sol-gel-hydrothermal synthesis and conductive properties of Al-doped ZnO nanopowders with controllable morphology. J Alloys Compd 587:692–697. https://doi.org/10.1016/j.jallcom.2013.10.24110.1016/j.jallcom.2013.10.241 ↗
53. Majumder SB, Jain M, Dobal PS, Katiyar RS (2003) Investigations on solution derived aluminium doped zinc oxide thin films. Mater Sci Eng B Solid State Mater Adv Technol 103:16–25. https://doi.org/10.1016/S0921-5107(03)00128-410.1016/S0921-5107(03)00128-4 ↗
54. Chang F-M, Brahma S, Huang J-H et al (2019) Strong correlation between optical properties and mechanism in deficiency of normalized self-assembly ZnO nanorods. Sci Rep 9:905. https://doi.org/10.1038/s41598-018-37601-810.1038/s41598-018-37601-8 ↗
55. Li J, Sathasivam S, Taylor A et al (2018) Single step route to highly transparent, conductive and hazy aluminium doped zinc oxide films. RSC Adv 8:42300–42307. https://doi.org/10.1039/c8ra09338e10.1039/c8ra09338e ↗
56. Zhu M, Huang H, Gong J et al (2007) Role of oxygen desorption during vacuum annealing in the improvement of electrical properties of aluminum doped zinc oxide films synthesized by sol gel method. J Appl Phys 102:043106. https://doi.org/10.1063/1.277259110.1063/1.2772591 ↗
57. Li Y, Yao R, Wang H et al (2017) Enhanced performance in Al-doped ZnO based transparent flexible transparent thin-film transistors due to oxygen vacancy in ZnO film with Zn–Al–O interfaces fabricated by atomic layer deposition. ACS Appl Mater Interfaces 9:11711–11720. https://doi.org/10.1021/acsami.7b0260910.1021/acsami.7b02609 ↗
58. Kim DN, Kim GH, Kim DL et al (2010) Thermal activation effects on the stoichiometry of indium zinc oxide thin-film transistors. Phys Status Solidi Appl Mater Sci 207:1689–1693. https://doi.org/10.1002/pssa.20098376210.1002/pssa.200983762 ↗
59. Danhara Y, Hirai T, Harada Y, Ohno N (2006) Exciton luminescence of ZnO fine particles. Phys Status Solidi Curr Top Solid State Phys 3:3565–3568. https://doi.org/10.1002/pssc.20067211010.1002/pssc.200672110 ↗
60. Sernelius BE, Berggren K-F, Jin Z-C et al (1988) Bandgap tailoring of ZnO by means of heavy Al doping. Phys Rev B 37:10244–10248. https://doi.org/10.1103/PhysRevB.37.1024410.1103/PhysRevB.37.10244 ↗
61. Beerbom MM, Lägel B, Cascio AJ et al (2006) Direct comparison of photoemission spectroscopy and in situ Kelvin probe work function measurements on indium tin oxide films. J Electron Spectros Relat Phenomena 152:12–17. https://doi.org/10.1016/j.elspec.2006.02.00110.1016/j.elspec.2006.02.001 ↗
62. Jiang X, Wong FL, Fung MK, Lee ST (2003) Aluminum-doped zinc oxide films as transparent conductive electrode for organic light-emitting devices. Appl Phys Lett 83:1875–1877. https://doi.org/10.1063/1.160580510.1063/1.1605805 ↗
63. Kim W, Maeng WJ, Kim M, Kim H (2011) Low pressure chemical vapor deposition of aluminum-doped zinc oxide for transparent conducting electrodes. J Electrochem Soc 158:495–499. https://doi.org/10.1149/1.359905510.1149/1.3599055 ↗
64. Krzywiecki M, Grządziel L, Sarfraz A et al (2015) Zinc oxide as a defect-dominated material in thin films for photovoltaic applications–experimental determination of defect levels, quantification of composition, and construction of band diagram. Phys Chem Chem Phys 17:10004–10013. https://doi.org/10.1039/c5cp00112a10.1039/c5cp00112a ↗
65. Sim H, Lee J, Cho S et al (2015) A study on the band structure of ZnO/CdS heterojunction for CIGS solar-cell application. JSTS J Semicond Technol Sci 15:267–275. https://doi.org/10.5573/JSTS.2015.15.2.26710.5573/JSTS.2015.15.2.267 ↗
66. Koo J, Cho JJ, Yang JH et al (2012) Surface modification of zinc oxide nanorods with Zn-porphyrin via metal-ligand coordination for photovoltaic applications. Bull Korean Chem Soc 33:636–640. https://doi.org/10.5012/bkcs.2012.33.2.63610.5012/bkcs.2012.33.2.636 ↗
67. Drewelow G, Reed A, Stone C et al (2019) Work function investigations of Al-doped ZnO for band-alignment in electronic and optoelectronic applications. Appl Surf Sci 484:990–998. https://doi.org/10.1016/j.apsusc.2019.04.07910.1016/j.apsusc.2019.04.079 ↗
68. Kaid MA, Ashour A (2007) Preparation of ZnO-doped Al films by spray pyrolysis technique. Appl Surf Sci 253:3029–3033. https://doi.org/10.1016/j.apsusc.2006.06.04510.1016/j.apsusc.2006.06.045 ↗
69. Nunes P, Fortunato E, Martins R (2001) Influence of the annealing conditions on the properties of ZnO thin films. Int J Inorg Mater 3:1125–1128. https://doi.org/10.1016/S1466-6049(01)00113-110.1016/S1466-6049(01)00113-1 ↗
70. de la Olvera ML, Gómez H, Maldonado A et al (2007) Doping, vacuum annealing, and thickness effect on the physical properties of zinc oxide films deposited by spray pyrolysis. Sol Energy Mater Sol Cells 91:1449–1453. https://doi.org/10.1016/j.solmat.2007.05.00710.1016/j.solmat.2007.05.007 ↗
71. Nunes P, Fortunato E, Tonello P et al (2002) Effect of different dopant elements on the properties of ZnO thin films. Vacuum 64:281–285. https://doi.org/10.1016/S0042-207X(01)00322-010.1016/S0042-207X(01)00322-0 ↗
72. Gómez-Pozos H, Maldonado A, de la Olvera ML (2007) Effect of the [Al/Zn] ratio in the starting solution and deposition temperature on the physical properties of sprayed ZnO: Al thin films. Mater Lett 61:1460–1464. https://doi.org/10.1016/j.matlet.2006.07.05310.1016/j.matlet.2006.07.053 ↗
73. Crossay A, Buecheler S, Kranz L et al (2012) Spray-deposited Al-doped ZnO transparent contacts for CdTe solar cells. Sol Energy Mater Sol Cells 101:283–288. https://doi.org/10.1016/j.solmat.2012.02.00810.1016/j.solmat.2012.02.008 ↗