journal article·2025Open access

MAPPING OF LOCAL DROPLET SIZE AND VELOCITY DISTRIBUTIONS IN FLAT-FAN SPRAYS USING HIGH-SPEED VIDEOGRAPHY

Zuhaib Nissar, Steven M. Begg, G. de Sercey, Oyuna Rybdylova

Atomization and Sprays· Volume 35· Issue 4

Abstract

A methodology based on high-speed photography has been developed to measure local droplet size and velocity distributions across the entire flow domain of a continuous, quasi-steady flat-fan water spray. The motivation is to complement phase Doppler anemometry (PDA) point measurements, which are limited to the far-field, dilute region of sprays. The nozzle was systematically shifted to capture a series of non-overlapping images of the spray, which were subsequently 'stitched' to form composite images. To reconstruct distributions along the stiches, four grids were used, each offset vertically and/or horizontally. Image analysis was employed to quantitatively evaluate the primary breakup zone and reconstruct droplet size and velocity distributions at all locations. Results showed that droplet sizes and velocities decrease downstream, with larger droplets and higher velocities observed at the periphery, attributed to rim tearing. Droplet sizes ranged from 10 to 250 μm, with velocities between 6 and 24 m/s. The local droplet size distributions were found to follow a log-normal distribution, consistent with previous observations. The local velocity distributions within the main spray region exhibited a Gaussian profile, whereas those along the spray periphery displayed a negatively skewed distribution, varying from monomodal to bimodal. At lower flow rates, the breakup zone contracted and shifted further from the nozzle. Rim tearing became dominant, leading to increased polydispersity and velocity fluctuations along the periphery.
Source: crossref · Quality: baseline

Research context

OpenAlex topics: Plant Surface Properties and Treatments · Electrohydrodynamics and Fluid Dynamics · Aerosol Filtration and Electrostatic Precipitation

SciVX discovery tags are terminology-based. OpenAlex topics are source-provided classifications.

References (48)

Show source-provided references
1. Allofs, D., Neeb, D., and Gulhan, A., Simultaneous Determination of Particle Size, Velocity, and Mass Flow in Dust-Laden Supersonic Flows, Exp. Fluids, vol. 63, no. 4, p. 64, 2022.10.1007/s00348-022-03402-z ↗
2. Altieri, A.L. and Cryer, S.A., Break-Up of Sprayed Emulsions from Flat-Fan Nozzles Using a Hole Kinematics Model, Biosyst. Eng., vol. 169, pp. 104-114, 2018.10.1016/j.biosystemseng.2018.02.006 ↗
3. Anez, J., Ahmed, A., Hecht, N., Duret, B., Reveillon, J., and Demoulin, F., Eulerian-Lagrangian Spray Atomization Model Coupled with Interface Capturing Method for Diesel Injectors, Int. J. Multiphase Flow, vol. 113, no. 9, pp. 325-342, 2019.10.1016/j.ijmultiphaseflow.2018.10.009 ↗
4. Asgarian, A., Heinrich, M., Schwarze, R., Bussmann, M., and Chattopadhyay, K., Experiments and Modeling of the Breakup Mechanisms of an Attenuating Liquid Sheet, Int. J. Multiphase Flow, vol. 130, p. 103347, 2020.10.1016/j.ijmultiphaseflow.2020.103347 ↗
5. Asgarian, A., Yang, Z., Tang, Z., Bussmann, M., and Chattopadhyay, K., An Image Feature Consolidation Technique (IFCT) to Capture Multi-Range Droplet Size Distributions in Atomizing Liquid Sheets, Exp. Fluids, vol. 61, no. 1, p. 14, 2019.10.1007/s00348-019-2847-6 ↗
6. Bachalo, W.D., Spray Diagnostics for the Twenty-First Century, Atomization Sprays, vol. 10, nos. 3-5, pp. 439-474, 2000.10.1615/AtomizSpr.v10.i3-5.110 ↗
7. Blaisot, J. and Yon, J., Entropy Based Image Analysis for the near Field of Direct Injection Diesel Jet, ILASS, Nottingham, UK, 2004.
8. Bush, J.W.M. and Hasha, A.E., On the Collision of Laminar Jets: Fluid Chains and Fishbones, J. Fluid Mech., vol. 511, pp. 285-310, 2004.10.1017/S002211200400967X ↗
9. Charalampous, G. and Hardalupas, Y., Collisions of Droplets on Spherical Particles, Phys. Fluids, vol. 29, no. 10, p. 103305, 2017.10.1063/1.5005124 ↗
10. Chaussonnet, G., Lieber, C., Yikang, Y., Gu, W., Bartschat, A., Reischl, M., Koch, R., Mikut, R., and Bauer, H.J., Towards DeepSpray: Using Convolutional Neural Network to Post-Process Shadowgraphy Images of Liquid Atomization, arXiv Preprint arXiv:1910.11073, 2019.
11. Chen, L., Li, G., Ma, X., Lim, J., and Sivathanu, Y., A Method for Measuring Planar Sauter Mean Diameter of Multi-Component Fuel Spray Based on the Combined Statistical Extinction Tomography and Particle Imaging Velocimetry, Fuel, vol. 214, pp. 154-164, 2018.10.1016/j.fuel.2017.10.110 ↗
12. Chen, X., Ma, D., Yang, V., and Popinet, S., High-Fidelity Simulations of Impinging Jet Atomization, Atomization Sprays, vol. 23, no. 12, pp. 1079-1101, 2013.10.1615/AtomizSpr.2013007619 ↗
13. Dombrowski, N. and Fraser, R.P., A Photographic Investigation into the Disintegration of Liquid Sheets, Phil. Trans. R. Soc. London Ser. A Math. Phys. Sci., vol. 247, no. 924, pp. 101-130, 1954.10.1098/rsta.1954.0014 ↗
14. Fdida, N. and Blaisot, J.B., Drop Size Distribution Measured by Imaging: Determination of the Measurement Volume by the Calibration of the Point Spread Function, Meas. Sci. Technol., vol. 21, no. 2, p. 025501, 2009.10.1088/0957-0233/21/2/025501 ↗
15. Fraser, R.P., Eisenklam, P., Dombrowski, N., and Hasson, D., Drop Formation from Rapidly Moving Liquid Sheets, AIChE J., vol. 8, no. 5, pp. 672-680, 1962.10.1002/aic.690080522 ↗
16. Gilet, T. and Bourouiba, L., Fluid Fragmentation Shapes Rain-Induced Foliar Disease Transmission, J. R. Soc. Interface, vol. 12, no. 104, p. 20141092, 2015.10.1098/rsif.2014.1092 ↗
17. Gong, C., Li, D., Kang, C., and Wang, Y., Visualisation of the Evolution of Perforations in Oil-Based Emulsion Sheets Formed by Flat-Fan Spray Nozzles, Biosyst. Eng., vol. 207, pp. 68-80, 2021.10.1016/j.biosystemseng.2021.04.005 ↗
18. Hart, D.P., PIV Error Correction, Exp. Fluids, vol. 29, no. 1, pp. 13-22, 2000.10.1007/s003480050421 ↗
19. Huang, H., Dabiri, D., and Gharib, M., On Errors of Digital Particle Image Velocimetry, Meas. Sci. Technol., vol. 8, no. 12, p. 1427, 1997.10.1088/0957-0233/8/12/007 ↗
20. ISO (International Organization for Standardization), 12233:2024(E) Digital Cameras—Resolution and Spatial Frequency Responses, Geneva, CH, 2024.
21. Jung, M., Kim, S., Lim, J., Lee, J., Jeong, S., Ku, D., Sun-Ik, N., and Minsung, K., Droplet Characterization of High-Flowrate Water Electrospray Using Shadowgraph Image Analysis, J. Mech. Sci. Technol., vol. 36, no. 4, pp. 2139-2148, 2022.10.1007/s12206-022-0346-9 ↗
22. Kashanj, S. and Kebriaee, A., The Effects of Different Jet Velocities and Axial Misalignment on the Liquid Sheet of Two Colliding Jets, Chem. Eng. Sci., vol. 206, pp. 235-248, 2019.10.1016/j.ces.2019.05.015 ↗
23. Kebriaee, A., Kashanj, S., and Olyaei, G., Fishbone Pattern Formation Due to Asymmetries in Colliding Low-Velocity Jets, Atomization Sprays, vol. 28, no. 8, pp. 751-762, 2018.10.1615/AtomizSpr.2018027196 ↗
24. Koegl, M., Hofbeck, B., Baderschneider, K., Mishra, Y.N., Huber, F.J.T., Berrocal, E., Will, S., and Zigan, L., Analysis of LIF and Mie Signals from Single Micrometric Droplets for Instantaneous Droplet Sizing in Sprays, Opt. Express, vol. 26, no. 24, pp. 31750-31766, 2018.10.1364/OE.26.031750 ↗
25. Kooij, S., Sijs, R., Denn, M.M., Villermaux, E., and Bonn, D., What Determines the Drop Size in Sprays, Phys. Rev. X, vol. 8, p. 031019, 2018.10.1103/PhysRevX.8.031019 ↗
26. Li, Y. and Rybdylova, O., Application of the Generalised Fully Lagrangian Approach to Simulating Polydisperse Gas-Droplet Flows, Int. J. Multiphase Flow, vol. 142, p. 103716, 2021.10.1016/j.ijmultiphaseflow.2021.103716 ↗
27. Lounnaci, K., Idlahcen, S., Sedarsky, D., Roze, C., Blaisot, J.B., and Demoulin, F.X., Image Processing Techniques for Velocity, Interface Complexity, and Droplet Production Measurement in the Near-Nozzle Region of a Diesel Spray, Atomization Sprays, vol. 25, no. 9, pp. 753-775, 2015.10.1615/AtomizSpr.2015011054 ↗
28. Machado, D.A., de Costa, F.S., de Andrade, J.C., Dias, G.S., and Achilles, F.G.A., Schlieren Image Velocimetry of Swirl Sprays, Flow, Turb. Combust., vol. 110, no. 2, pp. 489-513, 2023.10.1007/s10494-022-00385-z ↗
29. Makhnenko, I., Alonzi, E.R., Fredericks, S.A., Colby, C.M., and Dutcher, C.S., A Review of Liquid Sheet Breakup: Perspectives from Agricultural Sprays, J. Aerosol Sci., vol. 157, p. 105805, 2021.10.1016/j.jaerosci.2021.105805 ↗
30. Otsu, N., A Threshold Selection Method from Gray-Level Histograms, IEEE Transactions on Systems, Man, and Cybernetics, vol. 9, no. 1, pp. 62-66, 1979.10.1109/TSMC.1979.4310076 ↗
31. Panao, M.R.O., Why Drop Size Distributions in Sprays Fit the Lognormal, Phys. Fluids, vol. 35, no. 1, p. 011701, 2023.10.1063/5.0135510 ↗
32. Pernalete, C.G., Baten, J.v., Urbina, J.C., and Arevalo, J.F., A Molecular Reconstruction Feed Characterization and CAPE OPEN Implementation Strategy to Develop a Tool for Modeling HDT Reactors for Light Petroleum Cuts, 12th Int. Symp. on Process Systems Engineering and 25th European Symp. on Computer Aided Process Engineering, Copenhagen, Denmark, pp. 359-364, 2015.10.1016/B978-0-444-63578-5.50055-4 ↗
33. Rogoz, R., Teodorczyk, A., and Kapusta, L.J., Flash-Boiling Effect on the Droplet Size Distribution in Low-Pressure Sprays Formed at Various Ambient Pressures and Liquid Temperatures-Experimental Study and Modelling, Appl. Therm. Eng., vol. 236, p. 121740, 2024.10.1016/j.applthermaleng.2023.121740 ↗
34. Sazhin, S., Droplets and Sprays, London: Springer, 2014.10.1007/978-1-4471-6386-2 ↗
35. Sciacchitano, A. and Wieneke, B., PIV Uncertainty Propagation, Meas. Sci. Technol., vol. 27, no. 8, p. 084006, 2016.10.1088/0957-0233/27/8/084006 ↗
36. Sijs, R., Kooij, S., Holterman, H.J., van de Zande, J., and Bonn, D., Drop Size Measurement Techniques for Sprays: Comparison of Image Analysis, Phase Doppler Particle Analysis, and Laser Diffraction, AIP Adv., vol. 11, no. 1, p. 015315, 2021.10.1063/5.0018667 ↗
37. Sirignano, W.A., Fluid Dynamics and Transport of Droplets and Sprays, Cambridge, UK: Cambridge University Press, 2010.10.1017/CBO9780511806728 ↗
38. Squire, H.B., Investigation of the Instability of a Moving Liquid Film, Brit. J. Appl. Phys., vol. 4, no. 6, pp. 167-169, 1953.10.1088/0508-3443/4/6/302 ↗
39. Stafford, C.P. and Rybdylova, O., Robust Interpolation for Dispersed Gas-Droplet Flows Using Statistical Learning with the Fully Lagrangian Approach, Int. J. Numer. Methods Fluids, vol. 95, no. 11, pp. 1756-1790, 2023.10.1002/fld.5225 ↗
40. Stamhuis, E. and Thielicke, W., PIVlab-Towards User-Friendly, Affordable and Accurate Digital Particle Image Velocimetry in MATLAB, J. Open Res. Software, vol. 2, no. 1, 2014.10.5334/jors.bl ↗
41. Stiti, M., Garcia, S., Lempereur, C., Doublet, P., Kristensson, E., and Berrocal, E., Droplet Sizing in Atomizing Sprays Using Polarization Ratio with Structured Laser Illumination Planar Imaging, Opt. Lett., vol. 48, no. 15, pp. 4065-4068, 2023.10.1364/OL.495793 ↗
42. Vernay, C., Destabilisation of Liquid Sheets of Dilute Emulsions, Thesis, Universite Montpellier, 2015.
43. Vernay, C., Ramos, L., and Ligoure, C., Bursting of Dilute Emulsion-Based Liquid Sheets Driven by a Marangoni Effect, Phys. Rev. Lett., vol. 115, p. 198302, 2015.10.1103/PhysRevLett.115.198302 ↗
44. Villermaux, E. and Bossa, B., Drop Fragmentation on Impact, J. Fluid Mech., vol. 668, pp. 412-435, 2011.10.1017/S002211201000474X ↗
45. Wang, X., Wu, Y., Lv, Q., and Wu, X., Secondary Rainbow Refractometry for Droplet Refractive Index and Size Measurement, Opt. Lasers Eng., vol. 149, p. 106831, 2022a.10.1016/j.optlaseng.2021.106831 ↗
46. Wang, Y. and Bourouiba, L., Unsteady Sheet Fragmentation: Droplet Sizes and Speeds, J. Fluid Mech., vol. 848, pp. 946-967, 2018.10.1017/jfm.2018.359 ↗
47. Wang, Z., He, F., Zhang, H., Hao, P., Zhang, X., and Li, X., Characterization of the In-Focus Droplets in Shadowgraphy Systems via Deep Learning-Based Image Processing Method, Phys. Fluids, vol. 34, no. 11, p. 113316, 2022b.10.1063/5.0121174 ↗
48. Yarin, A., Drop Impact Dynamics: Splashing, Spreading, Receding, Bouncing, Ann. Rev. Fluid Mech., vol. 38, no. 1, pp. 159-192, 2006.10.1146/annurev.fluid.38.050304.092144 ↗