Martensitic transformation, magnetic entropy, and adiabatic temperature changes in bulk and ribbon Ni48Mn39.5Sn12.5−xInx (x = 2, 4, 6) metamagnetic shape memory alloys
Source abstract
Abstract
Abstract Martensitic transformation, magnetic entropy, and direct adiabatic temperature changes in Ni48Mn39.5Sn12.5−xInx (x = 2, 4, 6) metamagnetic Heusler bulk and grain-constrained ribbon alloys were studied. All alloys showed a typical L21 structure in austenite and the 4O structure in martensite. Their relative volume contributions changed depending on In content. With increasing In concentration, the martensitic transformation temperature increased, whereas the Curie temperature of austenite decreased. The magnetic entropy change under magnetic field of 5 T attained maximum of 20 J/kgK in the bulk and 14.4 J/kgK in the ribbon alloys with the Ni48Mn39.5Sn8.5In4 nominal composition. The corresponding adiabatic temperature change under 1.7 T yielded 1.3 K for the Ni48Mn39.5Sn8.5In4 bulk alloy. Despite grain confinement, melt spinning was found to stabilize martensite phase. Changes observed were discussed with relation to strengthened covalency imposed by In substitution. Graphic abstract
Source: crossref · Quality: baseline
Research context
OpenAlex topics: Shape Memory Alloy Transformations · Magnetic and transport properties of perovskites and related materials
SciVX discovery tags are terminology-based. OpenAlex topics are source-provided classifications.
References (65)
Show source-provided references
1. X. Moya, L.L. Manosa, A. Planes, T. Krenke, M. Acet, E.F. Wassermann, Martensitic transition and magnetic properties in Ni-Mn-X alloys. Mater. Sci. Eng. A 438–440, 911–915 (2006)10.1016/j.msea.2006.02.053 ↗
2. T. Krenke, X. Moya, S. Aksoy, M. Acet, P. Entel, L.L. Manosa, A. Planes, Y. Elerman, A. Yucel, E.F. Wassermann, Electronic aspects of the martensitic transition in Ni-Mn based Heusler alloys. J. Magn. Magn. Mater. 310, 2788–2789 (2007)10.1016/j.jmmm.2006.10.1139 ↗
3. M. Khan, I. Dubenko, S. Stadler, N. Ali, Magnetic and structural phase transitions in Heusler type alloys Ni2MnGa1-xInx. J. Phys. Condens. Matter 16, 5259–5266 (2004)10.1088/0953-8984/16/29/017 ↗
4. M. Ye, A. Kimura, Y. Miura, M. Shirai, Y.T. Cui, K. Shimada, H. Namatame, M. Taniguchi, S. Ueda, K. Kobayashi, R. Kainuma, T. Shishido, K. Fukushima, T. Kanomata, Role of electronic structure in the martensitic phase transition of Ni2Mn1+xSn1-x studied by hard X-ray photoelectron spectroscopy and ab initio calculations. Phys. Rev. Lett. 104, 176401 (2010)10.1103/PhysRevLett.104.176401 ↗
5. V. Sanchez-Alarcos, V. Recarte, J.I. Perez-Landazabal, C. Gomez-Polo, J.A. Rodriguez-Velamazan, Role of magnetism on the martensitic transformation in Ni-Mn-based magnetic shape memory alloys. Acta Mater. 60, 459–468 (2012)10.1016/j.actamat.2011.10.026 ↗
6. T. Krenke, M. Acet, E.F. Wassermann, X. Moya, L.L. Manosa, A. Planes, Martensitic transitions and the nature of ferromagnetism in the austenitic and martensitic states of Ni-Mn-Sn alloys. Phys. Rev. B 72, 014412 (2005)10.1103/PhysRevB.72.014412 ↗
7. W. Maziarz, P. Czaja, M.J. Szczerba, L. Lityńska-Dobrzyńska, T. Czeppe, J. Dutkiewicz, Influence of Ni/Mn concentration ratio on microstructure and martensitic transformation in melt-spun Ni-Mn-Sn Heusler alloy ribbons. J. Alloy. Compd. 615, S173–S177 (2014)10.1016/j.jallcom.2013.12.164 ↗
8. T. Krenke, E. Duman, M. Acet, X. Moya, L.L. Manosa, A. Planes, Effect of Co and Fe on the inverse magnetocaloric properties of Ni-Mn-Sn. J. Appl. Phys. 102, 033903 (2007)10.1063/1.2761853 ↗
9. J. Chen, Z. Han, B. Qian, P. Zhang, D. Wang, Y. Du, The influence of Al substitution on the phase transitions and magnetocaloric effect in Ni43Mn46Sn11-xAlx alloys. J. Magn. Magn. Mater. 323, 248–251 (2011). https://doi.org/10.1016/j.jmmm.2010.09.01510.1016/j.jmmm.2010.09.015 ↗
10. W. Maziarz, P. Czaja, M.J. Szczerba, J. Przewoźnik, C. Kapusta, A. Żywczak, T. Stobiecki, E. Cesari, J. Dutkiewicz, Room temperature magnetostructural transition in Al for Sn substituted Ni-Mn-Sn melt spun ribbons. J. Magn. Magn. Mater. 348, 8–16 (2013)10.1016/j.jmmm.2013.08.005 ↗
11. S. Chatterjee, S. Giri, S.K. De, S. Majumdar, Giant magneto-caloric effect near room temperature in Ni-Mn-Sn-Ga alloys. J. Alloys Compd. 503, 273–276 (2010)10.1016/j.jallcom.2010.05.026 ↗
12. Z.D. Han, D.H. Wang, C.L. Zhang, H.C. Xuan, J.R. Zhang, B.X. Gu, Y.W. Du, Effect of lattice contraction on martensitic transformation and magnetocaloric effect in Ge doped Ni-Mn-Sn alloys. Mater. Sci. Eng. B 157, 40–43 (2009)10.1016/j.mseb.2008.12.006 ↗
13. H.C. Xuan, P.D. Han, D.H. Wang, Y.W. Du, The influence of Ge substitution on the magnetostucture transition and magnetocaloric effect of Mn–Ni–Sn–Ge alloys. J. Alloys Compd. 582, 369–373 (2014). https://doi.org/10.1016/j.jallcom.2013.08.05310.1016/j.jallcom.2013.08.053 ↗
14. P. Czaja, J. Przewoźnik, C. Kapusta, W. Maziarz, The Ge enhanced exchange bias effect in Ni50Mn37.5Sn12.5 metamagnetic shape memory alloys. Mater. Res. Express 6, 106111 (2019)10.1088/2053-1591/ab3d85 ↗
15. W. Maziarz, P. Czaja, A. Wójcik, J. Dutkiewicz, J. Przewoźnik, E. Cesari, Microstructure and martensitic transformation of Ni50Mn37.5Sn12.5-xGex (x = 0, 1, 2, 3) Heusler alloys produced by various technologies. Mater. Today 2S, S523–S528 (2015)
16. H.C. Xuan, D.H. Wang, C.L. Zhang, Z.D. Han, H.S. Liu, B.X. Gu, Y.W. Du, The large low-field magnetic entropy changes in Ni43Mn46Sn11-xSbx alloys. Solid State Commun. 142, 591–594 (2007)10.1016/j.ssc.2007.04.007 ↗
17. M. Khan, J. Jung, S.S. Stoyko, A. Mar, A. Quetz, T. Samanta, I. Dubenko, N. Ali, S. Stadler, K.H. Chow, The role of Ni-Mn hybridization on the martensitic phase transitions in Mn-rich Heusler alloys. Appl. Phys. Lett. 100, 172403 (2012)10.1063/1.4705422 ↗
18. X. Wang, J.X. Shang, F.H. Wang, C.B. Jiang, H.B. Xu, Origin of unusual properties in the ferromagnetic Heusler alloy Ni-Mn-Sn: a first-principles investigation. Scripta Mater. 89, 33–36 (2014)10.1016/j.scriptamat.2014.06.027 ↗
19. H.B. Xiao, C.P. Yang, R.L. Wang, V.V. Marchenkov, X. Luo, Martensitic transformation and phase stability of In-doped Ni-Mn-Sn shape memory alloys from first-principles calculations. J. Appl. Phys. 115, 203703 (2014)10.1063/1.4878455 ↗
20. W. Maziarz, A. Wójcik, P. Czaja, A. Żywczak, J. Dutkiewicz, Ł Hawełek, E. Cesari, Magneto-structural transformations in Ni50Mn37.5Sn12.5-xInx Heusler powders. J. Magn. Magn. Mater. 412, 123–131 (2016)10.1016/j.jmmm.2016.03.089 ↗
21. Z. Guo, L. Pan, M. Yasir-Rafique, X. Zheng, H. Qiu, Z. Liu, Metamagnetic phase transformation and magnetocaloric effect in quinary Ni45Co5Mn40InxSn10-x Heusler alloy. J. Alloys Compd. 577, 174–178 (2013)10.1016/j.jallcom.2013.04.102 ↗
22. S. Dwevedi, B. Tiwari, Martensitic transformations and magnetocaloric effect in Sn-doped NiMnIn shape memory alloy. J. Alloys Compd. 540, 16–20 (2012)10.1016/j.jallcom.2012.06.057 ↗
23. W. Maziarz, P. Czaja, J. Dutkiewicz, R. Wróblewski, M. Leonowicz, Magnetic and martensitic transformations in Ni46Mn41.5-xFexSn12.5 melt spun ribbons. Mater. Sci. Forum 782, 23–30 (2014)10.4028/www.scientific.net/MSF.782.23 ↗
24. Y. Wang, Ch. Huang, J. Gao, S. Yang, X. Ding, X. Song, X. Ren, Evidence for ferromagnetic strain glass in Ni-Co-Mn-Ga Heusler alloy system. Appl. Phys. Lett. 101, 101913 (2012). https://doi.org/10.1063/1.475125010.1063/1.4751250 ↗
25. P. Czaja, A. Wierzbicka-Miernik, Ł Rogal, Segregation and microstructure evolution in chill cast and directionally solidified Ni-Mn-Sn metamagnetic shape memory alloys. J. Cryst. Growth. 492, 50–59 (2018)10.1016/j.jcrysgro.2018.04.006 ↗
26. W.M. Yuhasz, D.L. Schlagel, Q. Xing, K.W. Dennis, R.W. McCallum, T.A. Lograsso, Influence of annealing and phase decomposition on the magnetostructural transitions in Ni50Mn39Sn11. J. Appl. Phys. 105, 07A921 (2009)10.1063/1.3067855 ↗
27. C. Segui, E. Cesari, Composition and atomic order effects on the structural and magnetic transformations in ferromagnetic Ni-Co-Mn-Ga shape memory alloys. J. Appl. Phys. 111, 043914 (2012)10.1063/1.3688019 ↗
28. P. Czaja, M. Kowalczyk, W. Maziarz, On the magnetic contribution to the inverse magnetocaloric effect in Ni-Co-Cu-Mn-Sn metamagnetic shape memory alloys. J. Magn. Magn. Mater. 474, 381–392 (2019)10.1016/j.jmmm.2018.11.071 ↗
29. M. Nazmunnahar, L. Gonzalez, J.J. del Val, J. Gonzalez, J.J. Sunol, B. Hernando, Martensitic transformation in Ni50Mn50-xSnx (x = 11, 125) and Ni49Mn51-xSnx (x = 13) Heusler alloy. IEEE Trans. Magn. 48, 3749–3752 (2012)10.1109/TMAG.2012.2201703 ↗
30. A. Planes, L.L. Manosa, X. Moya, T. Krenke, M. Acet, E.F. Wassermann, Magnetocaloric effect in Heusler shape-memory alloys. J. Magn. Magn. Mater. 310, 2767–2769 (2007)10.1016/j.jmmm.2006.10.1041 ↗
31. H. Zheng, W. Wang, S. Xue, Q. Zhai, J. Frenzel, Z. Luo, Composition-dependent crystal structure and martenistic transformation in Heusler Ni-Mn-Sn alloys. Acta Mater. 61, 4648–4656 (2013)10.1016/j.actamat.2013.04.035 ↗
32. K. Koyama, K. Watanabe, T. Kanomata, R. Kainuma, K. Oikawa, K. Ishida, Observation of field induced reverse transformation in ferromagnetic shape memory alloy Ni50Mn36Sn14. Appl. Phys. Lett. 88, 132505–132513 (2006)10.1063/1.2189916 ↗
33. Q. Tao, Z.D. Han, J.J. Wang, B. Qian, P. Zhang, X.F. Jiang, D.H. Wang, Y.W. Du, Phase stability and magnetic-field-induced martensitic transformation in Mn-rich NiMnSn alloys. AIP Adv. 2, 042181–042188 (2012)10.1063/1.4772626 ↗
34. R. Kainuma, Y. Imano, W. Ito, Y. Sutou, H. Morito, S. Okamoto, O. Kitakami, K. Oikawa, A. Fujita, T. Kanomata, K. Ishida, Magnetic-field-induced shape recovery by reverse phase transformation. Nature 439, 957–960 (2006). https://doi.org/10.1038/nature0449310.1038/nature04493 ↗
35. Z.D. Han, D.H. Wang, C.L. Zhang, H.C. Xuan, B.X. Gu, Y.W. Du, Low-field inverse magnetocaloric effect in Ni50-xMn39+xSn11 Heusler alloys. Appl. Phys. Lett. 90, 042507–042513 (2007). https://doi.org/10.1063/1.243559310.1063/1.2435593 ↗
36. E.C. Passamani, E. Lozano, C. Larica, C.A.C. Marcelo, W.L. Scopel, I. Merino, A.L. Alves, A.Y. Takeuchi, V.P. Nascimento, Influence of chemical pressure in Sn-substituted Ni2MnGa Heusler alloy: experimental and theoretical studies. J. Appl. Phys. 112, 073921–073926 (2012)10.1063/1.4757951 ↗
37. S. Esakki Muthu, N.V. Rama Rao, M. Manivel Raja, S. Arumugam, K. Matsubayasi, Y. Uwatoko, Hydrostatic pressure effect on the martensitic transition, magnetic, and magnetocaloric properties in Ni50-xMn37+xSn13 Heusler alloys. J. Appl. Phys. 110, 083902 (2011). https://doi.org/10.1063/1.365137510.1063/1.3651375 ↗
38. E.C. Passamani, F. Xavier, E. Favre-Nicolin, C. Larica, A.Y. Takeuchi, I.L. Castro, J.R. Proveti, Magnetic properties of NiMn-based Heusler alloys influenced by Fe atoms replacing Mn. J. Appl. Phys. 105, 033919–033928 (2009)10.1063/1.3075835 ↗
39. H.C. Xuan, Y.X. Zheng, S.C. Ma, Q.Q. Cao, D.H. Wang, Y.W. Du, The martensitic transformation, magnetocaloric effect, and magnetoresistance in high-Mn content Mn47+xNi43-xSn10 ferromagnetic shape memory alloys. J. Appl. Phys. 108, 103920 (2010)10.1063/1.3511748 ↗
40. F.S. Liu, Q.B. Wang, S.P. Li, W.Q. Ao, J.Q. Li, The martensitic transition and magnetocaloric properties of Ni51Mn49-xSnx. Phys. B 412, 74–78 (2013)10.1016/j.physb.2012.12.024 ↗
41. R. Coll, L. Escoda, J. Saurina, J.L. Sanchez-Llamazares, B. Hernando, J.J. Sunol, Martensitic transformation in Mn–Ni–Sn Heusler alloys. J. Therm. Anal. Calorim. 99, 905–909 (2010). https://doi.org/10.1007/s10973-009-0489-210.1007/s10973-009-0489-2 ↗
42. H.S. Liu, C.L. Zhang, Z.D. Han, H.C. Xuan, D.H. Wang, Y.W. Du, The effect of Co doping on the magnetic entropy changes in Ni44−xCoxMn45Sn11 alloys. J. Alloys Compd. 467, 27–30 (2009). https://doi.org/10.1016/j.jallcom.2007.11.13710.1016/j.jallcom.2007.11.137 ↗
43. D.Y. Cong, S. Roth, M. Potschke, C. Hurrich, L. Schultz, Phase diagram and composition optimization for magnetic shape memory effect in Ni–Co–Mn–Sn alloys. Appl. Phys. Lett. 97, 021908 (2010). https://doi.org/10.1063/1.345423910.1063/1.3454239 ↗
44. W. Ito, X. Xu, R.Y. Umetsu, T. Kanomata, K. Ishida, R. Kainuma, Concentration dependence of magnetic moment in Ni50-xCoxMn50-yZy (Z = In, Sn) Heusler alloys. Appl. Phys. Lett. 97, 242515 (2010)10.1063/1.3525168 ↗
45. I. Dincer, E. Yuzuak, Y. Elerman, Influence of irreversibility on inverse magnetocaloric and magnetoresistance properties of the (Ni, Cu)50Mn36Sn14 alloys. J. Alloys Compd. 506, 508–512 (2010). https://doi.org/10.1016/j.jallcom.2010.07.06610.1016/j.jallcom.2010.07.066 ↗
46. C. Jing, Y.J. Yang, Z. Li, X.L. Wang, B.J. Kang, S.X. Cao, J.C. Zhang, J. Zhu, B. Lu, Tuning martensitic transformation and large magnetoresistance in Ni50-xCuxMn38Sn12 Heusler alloys. J. Appl. Phys. 113, 173902 (2013)10.1063/1.4803496 ↗
47. R. Das, S. Sarma, A. Perumal, A. Srinivasan, Effect of Co and Cu substitution on the magnetic entropy change in Ni46Mn43Sn11 alloy. J. Appl. Phys. 109, 07A901 (2011). https://doi.org/10.1063/1.354032710.1063/1.3540327 ↗
48. B. Gao, F.X. Hu, J. Shen, J. Wang, J.R. Sun, B.G. Shen, Field-induced structural transition and the related magnetic entropy change in Ni43Mn43Co3Sn11 alloy. J. Magn. Magn. Mater. 321, 2571–2574 (2009). https://doi.org/10.1016/j.jmmm.2009.03.04710.1016/j.jmmm.2009.03.047 ↗
49. C.L. Zhang, W.Q. Zou, H.C. Xuan, Z.D. Han, D.H. Wang, B.X. Gu, Y.W. Du, Giant low-field magnetic entropy changes in Ni45Mn44-xCrxSn11 ferromagnetic shape memory alloys. J. Phys. D: Appl. Phys. 40, 7287–7290 (2007). https://doi.org/10.1088/0022-3727/40/23/00510.1088/0022-3727/40/23/005 ↗
50. D.H. Wang, C.L. Zhang, Z.D. Han, H.C. Xuan, B.X. Gu, Y.W. Du, Large magnetic entropy changes and magnetoresistance in Ni45Mn42Cr2Sn11 alloy. J. Appl. Phys. 103, 033901 (2008). https://doi.org/10.1063/1.283694010.1063/1.2836940 ↗
51. F. Chen, Ch. Gong, Y. Guo, M. Zhang, Y. Chai, The effect of substitution of Ti for Mn on the martensitic transformation and magnetic entropy changes in Mn-rich Mn48-xTixNi42Sn10 alloys. Phys. Status Solidi A 210, 2762–2766 (2013). https://doi.org/10.1002/pssa.20133015410.1002/pssa.201330154 ↗
52. S. Li, Z. Lin, Z. Wang, J. Xu, L. Wang, J. Lin, Y. Hu, F. Xu, T.X. Nan, N.X. Sun, J.G. Duh, Large field-induced magnetocaloric effect in Ni43Mn46-xVxSn11 Heusler alloys. IEEE Trans. Magn. 48, 3985–3988 (2012). https://doi.org/10.1109/TMAG.2012.219928410.1109/TMAG.2012.2199284 ↗
53. H.C. Xuan, D.H. Wang, C.L. Zhang, Z.D. Han, B.X. Gu, Y.W. Du, Boron’s effect on martensitic transformation and magnetocaloric effect in Ni43Mn46Sn11Bx alloys. Appl. Phys. Lett. 92, 102503 (2008). https://doi.org/10.1063/1.289564510.1063/1.2895645 ↗
54. B. Gao, F. Shen, F.X. Hu, J. Wang, J.R. Sun, B.G. Shen, Magnetic properties and magnetic entropy change in Heusler alloys Ni50Mn35-xCuxSn15. Appl. Phys. A 97, 443–447 (2009). https://doi.org/10.1007/s00339-009-5239-610.1007/s00339-009-5239-6 ↗
55. D.H. Wang, C.L. Zhang, H.C. Xuan, Z.D. Han, J.R. Wang, J.R. Zhang, S.L. Tang, B.X. Gu, Y.W. Du, The study of low-field positive and negative magnetic entropy changes in Ni43Mn46-xCuxSn11 alloys. J. Appl. Phys. Lett. 102, 013909 (2007). https://doi.org/10.1063/1.275214010.1063/1.2752140 ↗
56. Z. Liu, Z. Wu, H. Yang, Y. Liu, W. Wang, X. Ma, G. Wu, Martensitic transformation and magnetic properties in ferromagnetic shape memory alloy Ni43Mn46Sn11-xSix. Intermetallics 19, 1605–1611 (2011). https://doi.org/10.1016/j.intermet.2011.06.00710.1016/j.intermet.2011.06.007 ↗
57. R. Saha, A.K. Nigam, Room temperature inverse magnetocaloric effect in Pd substituted Ni50Mn37Sn13 Heusler alloys. Phys. B 448, 263–266 (2014). https://doi.org/10.1016/j.physb.2014.04.01110.1016/j.physb.2014.04.011 ↗
58. P. Czaja, W. Maziarz, J. Przewoźnik, C. Kapusta, L. Hawelek, A. Chrobak, P. Drzymała, M. Fitta, A. Kolano-Burian, Magnetocaloric properties and exchange bias effect in Al For Sn substituted Ni48Mn39.5Sn12.5 Heusler alloy ribbons. J. Magn. Magn. Mater. 358–359, 142–148 (2014)10.1016/j.jmmm.2014.01.069 ↗
59. S. Agarwal, P.K. Mukhopadhyay, The effect of Al replacement and heat treatment on magnetocaloric properties of Ni2Mn-Sn ferromagnetic shape memory alloys. J. Alloys Compd. 608, 329–333 (2014)10.1016/j.jallcom.2014.04.095 ↗
60. H.B. Xiao, C.P. Yang, R.L. Wang, V.V. Marchenkov, K. Barner, J. Appl. Phys. 112, 123723–123725 (2012)10.1063/1.4772618 ↗
61. Y. Chieda, T. Kanomata, K. Fukushima, K. Matsubayashi, Y. Uwatoko, R. Kainuma, K. Oikawa, K. Ishida, K. Obara, T. Shishido, Magnetic properties of Mn-rich Ni2MnSn Heusler alloys under pressure. J. Alloys Compd. 486, 51–54 (2009). https://doi.org/10.1016/j.jallcom.2009.06.20610.1016/j.jallcom.2009.06.206 ↗
62. S. Esakki Muthu, N.V. Rama Rao, M. Manivel Raja, S. Arumugam, K. Matsubayasi, Y. Uwatoko, Hydrostatic pressure effect on the martensitic transition, magnetic, and magnetocaloric properties in Ni50-xMn37+xSn13 Heusler alloys. J. Appl. Phys. 110, 083902 (2011)10.1063/1.3651375 ↗
63. E. Sasioglu, L.M. Sandratskii, P. Bruno, First-principles calculation of the intersublattice exchange interactions and Curie temperatures of the full Heusler alloys Ni2MnX (X = Ga, In, Sn, Sb). Phys. Rev. B 70, 024427 (2004)10.1103/PhysRevB.70.024427 ↗
64. R.H. Kou, J. Gao, Y. Ren, B. Sanyal, S. Bhandary, S.M. Heals, B. Fisher, C.J. Sun, Charge transfer-tuned magnetism in Nd-substituted Gd5Si4. AIP Adv. 8, 125219 (2018). https://doi.org/10.1063/1.508145710.1063/1.5081457 ↗
65. J. Rodriguez-Carvajal, Recent advances in magnetic structure determination by neutron powder diffraction. Phys. B 192(1–2), 55–69 (1993). https://doi.org/10.1016/0921-4526(93)90108-I10.1016/0921-4526(93)90108-I ↗