Quasi-in situ observation of extension twinning of AZ31 magnesium alloy under co-directional dynamic compression
Source abstract
Abstract
In this paper, twinning nucleation and microstructure evolution of AZ31 magnesium alloy were investigated during the quasi-in situ dynamic compression. The microstructure characterization of the sample before and after deformation was performed via electron backscatter diffraction and transmission electron microscopy. The strain accommodation was estimated by selecting twinning variants and using the geometric compatibility factor (m`). The nucleation behavior of 55.4% extension twinning obeyed Schmid`s law under high strain rate compression. The non-Schmidt twinning variants with the highest geometric compatibility factor (m`) in the active twinning system of adjacent grains were activated in paired twins that affected the twining nucleation and variant selections.
Source: expertdata · Quality: candidate unverified · Source record ↗
Research context
OpenAlex topics: Magnesium Alloys: Properties and Applications · Aluminum Alloys Composites Properties · Hydrogen Storage and Materials
SciVX discovery tags are terminology-based. OpenAlex topics are source-provided classifications.
References (44)
Show source-provided references
1. Recent research on the deformation behavior of particle reinforced magnesium matrix composite: a review10.1007/s40195-019-00872-9 ↗
2. Recent research and developments on wrought magnesium alloys10.1016/j.jma.2017.09.001 ↗
3. Effect of rolling paths and pass reductions on the microstructure and texture evolutions of AZ31 sheet with an initial asymmetrical texture distribution10.1016/j.jallcom.2019.01.385 ↗
4. Effects of 5wt% polycaprolactone, polyhydroxybutyrate and polyvinyltrimethoxysilane on the properties of Ag/Zn/Mg alloy10.3390/ma15155421 ↗
5. Experimental study on tensile property of AZ31B magnesium alloy at different high strain rates and temperatures10.1016/j.matdes.2013.12.031 ↗
6. Effect of alloying and extrusion temperature on the microstructure and mechanical properties of Mg–Zn and Mg–Zn–RE alloys10.1016/j.msea.2014.09.085 ↗
7. Effect of chemical composition on the microstructure, tensile properties and fatigue behavior of sand-cast Mg–Gd–Y–Zr alloy10.1016/j.msea.2014.06.049 ↗
8. Orthotropic behavior of twin-roll-cast and hot-rolled magnesium ZAX210 sheet10.3390/ma15186437 ↗
9. Synergistic effects of solutes on active deformation modes, grain boundary segregation and texture evolution in Mg-Gd-Zn alloys10.1016/j.msea.2022.143348 ↗
10. In-situ TEM observation of {10-12} twin-dominated deformation of Mg pillars: twinning mechanism, size effects and rate dependency10.1016/j.actamat.2018.07.027 ↗
11. Quasi-in-situ investigation on extension twinning behavior of extruded ZC61 alloy during co-directional dynamic compression10.1016/j.msea.2021.141992 ↗
12. Basal slip mediated tension twin variant selection in magnesium WE43 alloy10.1016/j.actamat.2019.03.018 ↗
13. 〈a〉 Prismatic, 〈a〉 basal, and 〈c+a〉 slip strengths of commercially pure Zr by micro-cantilever tests10.1016/j.actamat.2015.06.020 ↗
14. Twinning-induced plasticity mechanism of α″-martensitic titanium alloy10.1016/j.actamat.2023.118763 ↗
15. Dislocation-modified high index twinning mechanisms in deformed magnesium alloy10.1016/j.jallcom.2019.02.079 ↗
16. Dynamic compressive behaviour and microstructural evolution of extrusion-shear Mg–6Zn–1Cu–1Y–0.6Zr alloy10.1080/02670836.2019.1630583 ↗
17. Microtexture evolution via deformation twinning and slip during compression of magnesium alloy AZ3110.1016/j.msea.2006.07.175 ↗
18. Strength and ductility with {1011}-{1012} double twinning in a magnesium alloy10.1038/ncomms11068 ↗
19. Variant selection during secondary twinning in Mg–3%Al10.1016/j.actamat.2010.03.027 ↗
20. On the selection of extension twin variants with low Schmid factors in a deformed Mg alloy10.1016/j.actamat.2014.10.004 ↗
21. The role of strain accommodation during the variant selection of primary twins in magnesium10.1016/j.actamat.2010.12.005 ↗
22. Variant selection of primary, secondary and tertiary twins in a deformed Mg alloy10.1016/j.actamat.2012.01.014 ↗
23. Twinning characteristic in tension of magnesium alloys and its effect on mechanical properties10.1016/j.matdes.2016.06.073 ↗
24. Twinning characteristic and variant selection in compression of a pre-side-rolled Mg alloy sheet10.1016/j.msea.2014.07.026 ↗
25. Grain neighbour effects on twin transmission in hexagonal close-packed materials10.1038/ncomms13826 ↗
26. An in situ study of microstructural strain localization and damage evolution in an (α+ β) Ti-Al-V-Fe-Si-O alloy10.1016/j.actamat.2022.118424 ↗
27. Crystallographic analysis on the primary and secondary extension twin variants in Mg alloys10.1088/1757-899X/375/1/012021 ↗
28. Breakdown of the Schmid law in homogeneous and heterogeneous nucleation events of slip and twinning in magnesium10.1016/j.jmps.2012.06.015 ↗
29. Effect of pre-strain on extension twinning behavior in an extruded AZ31 Mg alloy observed by in-situ EBSD10.1016/j.matchar.2023.112893 ↗
30. Study on high speed impact deformation behaviors of Mg-1Al-4Y by SHPB10.1088/2053-1591/abc5e1 ↗
31. Microstructure evolution and constitutive relation establishment of Mg–7Gd–5Y–1.2Nd–0.5Zr alloy under high strain rate after severe multi-directional deformation10.1016/j.msea.2021.140994 ↗
32. In situ observations of crack propagation in as-cast Cu-1.5Fe-0.5Co (wt%) alloy10.1016/j.msea.2017.08.055 ↗
33. Effect of {10-12} twinning on the deformation behavior of AZ31 magnesium alloy10.1016/j.msea.2019.01.021 ↗
34. Microstructure characterization of ZK60 magnesium alloys using TEM and HR-EBSD10.1017/S1431927613012221 ↗
35. Twinning effects on the hot deformation behavior of AZ31 Mg alloy10.1016/j.matchar.2016.06.014 ↗
36. Deformation micro-mechanism for compression of magnesium alloys at room temperature analyzed by electron backscatter diffraction10.1016/j.matdes.2014.09.061 ↗
37. Use of Schmid factors to select extension twin variants in extruded magnesium alloy tubes10.1016/j.scriptamat.2006.07.059 ↗
38. Breakdown of the Schmid law in homogeneous and heterogeneous nucleation events of slip and twinning in magnesium10.1016/j.jmps.2012.06.015 ↗
39. Nucleation and growth analysis of {10-12} extension twins in AZ31 magnesium alloy during in-situ tension10.1016/j.jallcom.2019.152967 ↗
40. Understanding of variant selection and twin patterns in compressed Mg alloy sheets via combined analysis of Schmid factor and strain compatibility factor10.1016/j.msea.2014.04.103 ↗
41. Plastic relaxation of the internal stress induced by twinning10.1016/j.actamat.2013.09.024 ↗
42. Dislocation induced twin growth and formation of basal stacking faults in {10-12} twins in pure Mg10.1016/j.actamat.2018.12.003 ↗
43. Variant selection of primary, secondary and tertiary twins in a deformed Mg alloy10.1016/j.actamat.2012.01.014 ↗
44. Non-Schmid behaviour during secondary twinning in a polycrystalline magnesium alloy10.1016/j.actamat.2007.08.034 ↗