Informing quantum materials discovery and synthesis using X-ray micro-computed tomography
Source abstract
Abstract
Abstract The presence of inclusions, twinning, and low-angle grain boundaries, demanded to exist by the third law of thermodynamics, drive the behavior of quantum materials. Identification and quantification of these structural complexities often requires destructive techniques. X-ray micro-computed tomography (µCT) uses high-energy X-rays to non-destructively generate 3D representations of a material with micron/nanometer precision, taking advantage of various contrast mechanisms to enable the quantification of the types and number of inhomogeneities. We present case studies of µCT informing materials design of electronic and quantum materials, and the benefits to characterizing inclusions, twinning, and low-angle grain boundaries as well as optimizing crystal growth processes. We discuss recent improvements in µCT instrumentation that enable elemental analysis and orientation to be obtained on crystalline samples. The benefits of µCT as a non-destructive tool to analyze bulk samples should encourage the community to adapt this technology into everyday use for quantum materials discovery.
Source: crossref · Quality: baseline
Research context
OpenAlex topics: Electronic and Structural Properties of Oxides · High-pressure geophysics and materials · Advanced X-ray and CT Imaging
SciVX discovery tags are terminology-based. OpenAlex topics are source-provided classifications.
References (70)
Show source-provided references
1. National Research Council. Frontiers in Crystalline Matter: From Discovery to Technology (The National Academies Press, 2009).
2. Broholm, C. et al. Basic research needs workshop on quantum materials for energy relevant technology. https://doi.org/10.2172/1616509 (2016).10.2172/1616509 ↗
3. Sarrao, J. et al. Basic research needs for superconductivity. https://doi.org/10.2172/899129 (2006).10.2172/899129 ↗
4. Thornton, P. A. The influence of nonmetallic inclusions on the mechanical properties of steel: a review. J. Mater. Sci. 6, 347–356 (1971).10.1007/PL00020378 ↗
5. Zhang, L. & Thomas, B. G. State of the art in the control of inclusions during steel ingot casting. Metall. Mater. Trans. B 37, 733–761 (2006).10.1007/s11663-006-0057-0 ↗
6. Zhang, P. et al. Enhancing carrier transport properties of melt-grown CsPbBr3 single crystals by eliminating inclusions. Cryst. Growth Des. 20, 2424–2431 (2020).10.1021/acs.cgd.9b01616 ↗
7. Zhang, L. T., Tsutsui, M., Ito, K. & Yamaguchi, M. Effects of ZnSb and Zn inclusions on the thermoelectric properties of β-Zn4Sb3. J. Alloy. Comp. 358, 252–256 (2003).10.1016/S0925-8388(03)00074-4 ↗
8. Gurevich, A. & Pashitskii, E. A. Current transport through low-angle grain boundaries in high-temperature superconductors. Phys. Rev. B 57, 13878 (1998).10.1103/PhysRevB.57.13878 ↗
9. Durrell, J. H. & Rutter, N. A. Importance of low-angle grain boundaries in YBa2Cu3O7-δ coated conductors. Supercond. Sci. Technol. 22, 013001 (2009).10.1088/0953-2048/22/1/013001 ↗
10. Maeno, Y. et al. Enhancement of superconductivity of Sr2RuO4 to 3 K by embedded metallic microdomains. Phys. Rev. Lett. 81, 3765–3768 (1998).10.1103/PhysRevLett.81.3765 ↗
11. Jin, R., Zadorozhny, Yu. & Liu, Y. Observation of anomalous temperature dependence of the critical current in Pb/Sr2RuO4/Pb junctions. Phys. Rev. B 59, 4433–4438 (1999).10.1103/PhysRevB.59.4433 ↗
12. Ying, Y. A. et al. Enhanced spin-triplet superconductivity near dislocations in Sr2RuO4. Nat. Commun. 4, 2596 (2013).10.1038/ncomms3596 ↗
13. Bianco, E. & Kourkoutis, L. F. Atomic-resolution cryogenic scanning transmission electron microscopy for quantum materials. Acc. Chem. Res. 54, 3277–3287 (2021).10.1021/acs.accounts.1c00303 ↗
14. Venables, J. A., Smith, D. J. & Cowley, J. M. HREM, STEM, REM, SEM-and STM. Surf. Sci. 181, 235–249 (1987).10.1016/0039-6028(87)90164-6 ↗
15. Becker, J. S. & Dietze, H.-J. Inorganic trace analysis by mass spectrometry. Spectrochim. Acta B: . Spectrosc. 53, 1475–1506 (1998).10.1016/S0584-8547(98)00110-4 ↗
16. Stock, S. R. X-ray microtomography of materials. Int. Mater. Rev. 44, 141–164 (1999).10.1179/095066099101528261 ↗
17. Ritman, E. L. Micro-computed tomography-current status and developments. Annu. Rev. Biomed. Eng. 6, 185–208 (2004).10.1146/annurev.bioeng.6.040803.140130 ↗
18. Rawson, S. D., Maksimcuka, J., Withers, P. J. & Cartmell, S. H. X-ray computed tomography in life sciences. BMC Biol. 18, 21 (2020).10.1186/s12915-020-0753-2 ↗
19. Hanna, R. D. & Ketcham, R. A. X-ray computed tomography of planetary materials: a primer and review of recent studies. Geochemistry 77, 547–572 (2017).10.1016/j.chemer.2017.01.006 ↗
20. Vásárhelyi, L., Kónya, Z., Kukovecz, Á. & Vatjai, R. Microcomputed tomography-based characterization of advanced materials: a review. Mater. Today Adv. 8, 100084 (2020).10.1016/j.mtadv.2020.100084 ↗
21. Phelan, W. A. et al. On the chemistry and physical properties of flux and floating zone grown SmB6 single crystals. Sci. Rep. 6, 20860 (2016).10.1038/srep20860 ↗
22. Berry, T., Pressley, L. A., Phelan, W. A., Tran, T. T. & McQueen, T. M. Laser enhanced single crystal growth of non-symmorphic materials: applications to an eight-fold fermion candidate. Chem. Mater. 13, 5827–5834 (2020).10.1021/acs.chemmater.0c01721 ↗
23. Sinha, M. et al. Twisting of 2D kagome sheets in layered intermetallics. ACS Cent. Sci. 7, 1381–1390 (2021).10.1021/acscentsci.1c00599 ↗
24. ASTM. Standard guide for computed tomography (CT) imaging. in Annual Book of ASTM Standards, Section 3 Metals Test Methods and Analytical Procedures 690–713 (ASTM, 1992).
25. Rudolph, P. Defect formation during crystal growth from the melt. In Handbook of Crystal Growth (eds Dhanaraj, G., Byrappa, K., Prasad, V., Dudley, M.) 159–201 (Springer Heidelberg Dordrecht London New York, 2010).10.1007/978-3-540-74761-1_6 ↗
26. Hu, Z. W. et al. Synchrotron topographic characterization of Fe-doped flux-grown Potassium Niobate Tantalate. Appl. Phys. Lett. 61, 648 (1992).10.1063/1.107810 ↗
27. Sadrabadi, P. et al. Evolution of dislocation structure and deformation resistance in creep exemplified on single crystals of CaF2. Mater. Sci. Eng. A 510–511, 46–50 (2009).10.1016/j.msea.2008.04.086 ↗
28. Cockayne, B. Developments in melt-grown oxide crystals. J. Cryst. Growth 3–4, 60–70 (1968).10.1016/0022-0248(68)90101-2 ↗
29. Wang, X., Wang, J., Yu, Y., Zhang, H. & Boughton, R. I. Growth of cubic KTa1-xNbO3 crystal by Czochralski method. J. Cryst. Growth 293, 398–403 (2006).10.1016/j.jcrysgro.2006.05.021 ↗
30. Polgár, K., Peter, À., Földvári, I. & Szaller, Z. Structural defects in flux-grown stoichiometric LiNbO3 single crystals. J. Cryst. Growth 218, 327–333 (2000).10.1016/S0022-0248(00)00600-X ↗
31. Saeedi, H. et al. Thermal shocks influence on the growth process and optical quality of Nd: YAG crystal. J. Cryst. Growth 363, 171–175 (2013).10.1016/j.jcrysgro.2012.10.035 ↗
32. Föll, H. & Kolbesen, B. O. Formation and nature of swirl defects in silicon. Appl. Phys. 8, 319–331 (1975).10.1007/BF00898366 ↗
33. Falster, R. & Voronkov, V. V. The engineering of intrinsic point defects in silicon wafers and crystals. Mater. Sci. Eng. B 73, 87–94 (2000).10.1016/S0921-5107(99)00439-0 ↗
34. Montes, J. M., Rodríguez, J. A. & Herrera, E. J. Thermal and electrical conductivities of sintered powder compacts. Powder Met. 46, 251–256 (2013).10.1179/003258903225008544 ↗
35. Rondinelli, J. M. et al. Accelerating functional materials discovery. Am. Ceram. Soc. Bull. 92, 9 (2013).
36. Phelan, W. A. et al. Adventures in crystal growth: synthesis and characterization of single crystals of complex intermetallic compounds. Chem. Mater. 24, 409–420 (2012).10.1021/cm2019873 ↗
37. Bugaris, D. E. & Loye, H.-C. Materials discovery by flux crystal growth: quaternary and higher order oxides. Angew. Chem. Int. Ed. 51, 3780–3811 (2012).10.1002/anie.201102676 ↗
38. Canfield, P. C. & Fisk, Z. Growth of single crystals from metallic fluxes. Philos. Mag. B 65, 1117–1123 (1991).10.1080/13642819208215073 ↗
39. Rosa, P. F. S. & Fisk, Z. Bulk and surface properties of SmB6. In Rare-Earth Borides (ed. Inosov, D.) 817–875 (Jenny Stanford Publishing, 2021).10.1201/9781003146483-11 ↗
40. Thomas, S. M. et al. Quantum oscillations in flux-grown SmB6 with embedded aluminum. Phys. Rev. Lett. 112, 166401 (2019).10.1103/PhysRevLett.122.166401 ↗
41. Ketcham, R. A. Computational methods for quantitative analysis of three-dimensional features in geological specimens. Geosphere 1, 32–41 (2005).10.1130/GES00001.1 ↗
42. Ketcham, R. A. Three-dimensional grain fabric measurements using high-resolution X-ray computer tomography. J. Struct. Geol. 2, 1217–1228 (2005).10.1016/j.jsg.2005.02.006 ↗
43. Smit, Th. H., Schneider, E. & Odgaard, A. Star length distribution: a volume-based concept for the characterization of structural anisotropy. J. Microsc. 191, 249–257 (1998).10.1046/j.1365-2818.1998.00394.x ↗
44. Naumann, M. et al. Fermi surface of the Skutterudite CoSb3: quantum oscillations and band-structure calculations. Phys. Rev. B 103, 085133 (2021).10.1103/PhysRevB.103.085133 ↗
45. Chae, S. et al. Toward the predictive discovery of ambipolarly dopable ultra-wide-band-gap semiconductors: the case of rutile GeO2. Appl. Phys. Lett. 118, 260501 (2021).10.1063/5.0056674 ↗
46. Niedermeier, C. A., Ide, K., Katase, T., Hosono, H. & Kamiya, T. Shallow valence band of rutile GeO2 and P-type doping. J. Phys. Chem. C. 124, 25721–25728 (2020).10.1021/acs.jpcc.0c07757 ↗
47. Takane, H. & Kaneko, K. Establishment of a growth route of crystallized rutile GeO2 thin film (≧1 µm/h) and its structural properties. Appl. Phys. Lett. 119, 062104 (2021).10.1063/5.0060785 ↗
48. Morey, J. R. et al. Growth and characterization of iron scandium sulfide (FeSc2S4). J. Cryst. Growth 454, 128–133 (2016).10.1016/j.jcrysgro.2016.09.014 ↗
49. Yu, P. et al. Correlation between Te inclusions and the opto-electrical properties of CdMnTe and CdMgTe single crystals. J. Cryst. Growth 571, 126259 (2021).10.1016/j.jcrysgro.2021.126259 ↗
50. Su, H. et al. Distribution control and formation mechanism of gas Inclusions in directionally solidified Al2O3-Er3Al5O12-ZrO2 ternary eutectic ceramic by laser floating zone melting. J. Mater. Sci. Technol. 66, 21–27 (2021).10.1016/j.jmst.2020.03.085 ↗
51. Berry, T., Bernier, S., Auffermann, G., McQueen, T. M. & Phelan, W. A. Laser floating zone growth of SrVO3 single crystals. J. Cryst. Growth 583, 126518 (2022).10.1016/j.jcrysgro.2022.126518 ↗
52. Dabkowska, H. A. & Dabkowski, A. B. Crystal growth of oxides by optical floating zone technique. In Springer Handbook of Crystal Growth (eds Dhanaraj, G., Byrappa, K., Prasad, V., Dudley, M.) 367–390 (Springer Heidelberg Dordrecht London New York, 2010).10.1007/978-3-540-74761-1_12 ↗
53. Phelan, W. A., Zahn, J., Kennedy, Z. & McQueen, T. M. Pushing boundaries: high pressure, supercritical optical floating zone materials discovery. J. Sol. St. Chem. 270, 705–709 (2019).10.1016/j.jssc.2018.12.013 ↗
54. Li, Y. et al. Rare-earth triangular lattice spin liquid: a single-crystal study of YbMgGaO4. Phys. Rev. Lett. 115, 167203 (2015).10.1103/PhysRevLett.115.167203 ↗
55. Paddison, J. A. M. et al. Continuous excitations of the triangular-lattice quantum spin liquid YbMgGaO4. Nat. Phys. 13, 117–122 (2017).10.1038/nphys3971 ↗
56. Egan, C. K. et al. 3D chemical imaging in the laboratory by hyperspectral X-ray computed tomography. Sci. Rep. 5, 15979 (2015).10.1038/srep15979 ↗
57. Ludwig, W. et al. Three-dimensional grain mapping by X-ray diffraction contrast tomography and the use of Friedel pairs in diffraction data analysis. Rev. Sci. Instrum. 80, 033905 (2009).10.1063/1.3100200 ↗
58. McDonald, S. A. et al. Microstructural evolution during sintering of copper particles studied by laboratory diffraction contrast tomography (LabDCT). Sci. Rep. 7, 5251 (2017).10.1038/s41598-017-04742-1 ↗
59. Qu, K. et al. Morphology and growth habit of the new flux-grown layered semiconductor KBiS2 revealed by diffraction contrast tomography. Cryst. Growth Des. 22, 3228–3234 (2022).10.1021/acs.cgd.2c00078 ↗
60. Wright, C. J. ‘C. J. ’ et al. Toward in situ synchrotron mapping of crystal selection processes during crystal growth. Chem. Mater. 33, 3359–3367 (2021).10.1021/acs.chemmater.1c00602 ↗
61. Higuchi, M., Hosokawa, T. & Kimura, S. Growth of rutile single crystals by floating zone method. J. Cryst. Growth 112, 354–358 (1991).10.1016/0022-0248(91)90310-2 ↗
62. Hu, B. Q., Zhang, Y. Z., Wu, X. & Chen, X. L. Defects in large single crystals Nd:YVO4. J. Cryst. Growth 226, 511–516 (2001).10.1016/S0022-0248(01)01422-1 ↗
63. Witteveen, C. et al. Polytypism and superconductivity in the NbS2 system. Dalton Trans. 50, 3216–3223 (2021).10.1039/D0DT03636F ↗
64. Sung, N. H. et al. Crystal growth and intrinsic magnetic behavior of Sr2IrO4. Philos. Mag. 96, 413–426 (2016).10.1080/14786435.2015.1134835 ↗
65. Haynes, A. S., Stoumpos, C. C., Chen, H., Chica, D. & Kanatzidis, M. G. Panoramic synthesis as an effective materials discovery tool: the system Cs/Sn/P/Se as a test case. J. Am. Chem. Soc. 139, 10814–10821 (2017).10.1021/jacs.7b05423 ↗
66. Xia, F. et al. Understanding solvothermal crystallization of mesoporous anatase beads by in situ synchrotron PXRD and SAXS. Chem. Mater. 26, 4563–4571 (2014).10.1021/cm501810x ↗
67. Chae, S. et al. Germanium dioxide: a new rutile substrate for epitaxial film growth. J. Vac. Sci. Tech. A 40, 050401 (2022).10.1116/6.0002011 ↗
68. Ketcham, R. A. & Hildebrandt, J. Characterizing, measuring, and utilizing the resolution of CT imagery for improved quantification of fine-scale features. Nucl. Instrum. Methods Phys. Res. B: Beam Interact. Mater. 324, 80–87 (2014).10.1016/j.nimb.2013.08.064 ↗
69. Berger, M. J. et al. XCOM: Photon cross sections database (version 1.5). [Online] Available: http://physics.nist.gov/xcom [2022, December 17] National Institute of Standards and Technology, Gaithersburg, MD (2010).
70. Momma, K. & Izumi, F. VESTA: a three-dimensional visualization system for electronic and structural analysis. J. Appl. Cryst. 41, 654–658 (2008).10.1107/S0021889808012016 ↗